2008 Dodge Sprinter 3500

No clear pattern

0% of complaints about the 2008 Dodge Sprinter 3500 arrived in its first year of service. That is an unusual figure for a 2008 vehicle, but with only 43 complaints on record the sample is too small to call it a pattern — the margin of error covers the range where ordinary vehicles sit. The figures below are reported without a verdict. The most-reported system is air bags (33 complaints), typically at 8.4 yr or about 47,574 miles.

Complaints: 43
Median age at failure: 8.4 yr
Median mileage: 23,000 n=10
Crash / fire / tow: 7% of reports
Safety recalls: 6

Safety recalls — NHTSA campaigns

17V478000 2017-07-28

Air bags:frontal:passenger side:inflator module

Daimler Vans USA, LLC (DVUSA) is recalling certain 2007-2009 Freightliner and Dodge Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled into the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

16V077000 2016-02-10

Air bags:frontal:driver side:inflator module

Daimler Vans USA, LLC (Daimler Vans) is recalling certain model year 2007-2009 Dodge Sprinter 2500 and 3500 vehicles manufactured July 1, 2006, to July 31, 2008, 2007-2014 Freightliner Sprinter 2500 and 3500 vehicles manufactured July 1, 2006, to July 1, 2014, and 2010-2014 Mercedes Benz Sprinter 2500 and 3500 vehicles manufactured July 1, 2010, to July 1, 2014. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

14V706000 2014-11-05

Equipment adaptive/mobility

Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

11V210000 2011-03-30

Seat belts

MERCEDES-BENZ IS RECALLING CERTAIN MODEL YEAR 2008-2011 2500 AND 3500 SPRINTER VEHICLES EQUIPPED WITH AN OPTIONAL THREE-SEAT BENCH IN THE PASSENGER COMPARTMENT. THE SEAT BENCHES IN THE SECOND SEATING ROW MAY HAVE BEEN EQUIPPED WITH SAFETY BELTS THAT DO NOT MEET THE MINIMUM REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, "OCCUPANT PROTECTION IN INTERIOR IMPACT," AND MOTOR VEHICLE SAFETY STANDARD 209, "SEAT BELT ASSEMBLIES." FIRST, THOSE SAFETY BELTS MAY NOT LOCK AS REQUIRED. SECOND, THE ASSEMBLY LOOP MAY NOT PERFORM TO MINIMUM FORCE REQUIREMENTS.

IN THE EVENT OF A CRASH, THE SAFETY BELTS IN THESE VEHICLES MAY NOT PERFORM AS REQUIRED SUCH THAT A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY OR DEATH IN THE EVENT OF A CRASH.

08V352000 2008-07-29

Power train:driveline:driveshaft

SPRINTER IS RECALLING 79 MY 2008 DODGE AND FREIGHTLINER 3500 TRUCKS. SOME OF THE LEFT DRIVE SHAFTS ON THE REAR AXLE WHICH WERE LABELED WITH THE CHARGE INDICATOR "S," MAY CONTAIN CRACKS AT THE RADIUS BETWEEN THE SHAFT AND THE FLANGE.

THESE CRACKS MAY CAUSE A BREAKAGE OF THE DRIVE SHAFT INCREASING THE RISK OF CRASH.

08V110000 2008-03-11

Service brakes, hydraulic:foundation components:master cylinder

SPRINTER IS RECALLING 34 MY 2007-2008 DODGE AND FREIGHTLINER SPRINTER 3500 CARGO VANS. SOME OF THESE VANS MAY NOT HAVE HAD THE CORRECT BRAKE COMPONENTS INSTALLED.

THIS COULD RESULT IN POOR BRAKING PERFORMANCE, INCREASING THE RISK OF A CRASH.

In owners’ own words

Air bags mileage not reported 7.7 yr in service

TL* THE CONTACT OWNS A 2008 DODGE SPRINTER 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V312000 (AIR BAGS) HOWEVER, THE PARTS NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Air bags mileage not reported 7.8 yr in service

TL* THE CONTACT OWNS A 2008 DODGE SPRINTER 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V354000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Air bags mileage not reported 7.9 yr in service

TL* THE CONTACT OWNS A 2008 DODGE SPRINTER 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V354000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

How to read this

This is what owners reported, not a reliability rating. People file with NHTSA about alarming failures, not routine ones, and complaint volume tracks how many cars were sold.
Failure ages come from the incident date on each complaint, populated on about 83% of records. Mileage is shown where reported — NHTSA’s 2021 system change cut mileage capture to roughly 15%, so it thins out sharply after MY2020.
Every rank compares this vehicle only against others of the same model year. A 2025 car has not had time to accumulate five-year failures, so comparing early-failure share across years is meaningless.
Fourteen make-months distorted by media storms and mass recalls — Toyota in February 2010 ran 11× normal volume across 33 models — are excluded.
Recalls are manufacturer actions and authoritative; complaints are not. A recall listed here may already have been performed on any individual car. Check a specific VIN at nhtsa.gov/recalls.

2008 Dodge Sprinter 3500

When each system is reported — middle 50% of complaints

Safety recalls — NHTSA campaigns

In owners’ own words

How to read this