10% of complaints about the 2002 Chevrolet Venture came in the first year, which is unremarkable for a 2002 vehicle — around the middle of the 230 model-years on record. The median complaint arrives at 3.7 yr in service. The most-reported system is engine cooling (41 complaints), typically at 5.2 yr or about 65,000 miles.
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
THE VEHICLE IS A RENTAL VEHICLE. CUSOTMER RENTED THE VAN AND WENT OUT TO THE LOT TO PUT HIS BELONGINS IN THE VEHICLE. WHEN HE PULLED ON THE HANDLE TO CLOSE THE HATCH, THE PLASTIC HOUSING BROKE AND THE HANDLE CAME LOOSE, THERE IS A METAL BOLD THAT WAS ATTACHED TO THE PLASTIC, THAT PIECE CUT THE CUSTOMERS HAND RIGHT HAND, BETWEEN HIS THUMB AND INDEX FINGER. HIS WOUND WAS CLEANED BY THE FIRST AID AT THE AIRPORT AND THEN WE TRANSPORTED HIM TO DEL SOL MEDICAL CENTER WHERE HIS WOUND WAS SEALED WITH MEDICAL "GLUE" INSTEAD OF STITCHES AND HE RECEIVED A TETANUS SHOT. *AK
THE REAR HANDLE ON THE REAR HATCH BROKE, THE PLASTIC HOUSING THAT HOLDS THE HANDLE BROKE, LIKE IF THE PLASTIC IS NOT STRONG ENOUGH TO SUPPORT THE FORCES EXERTED ON THE HANDLE.
THE WINDSHIELD LEAKED WATER DOWN THROUGH THE OVERHEAD INSTRUMENT CLUSTER ALONG TO THE TOP OF THE WINDOW. *TT THE VEHICLE STALLED, HESITATED DURING ACCELERATION AND THE PASSENGER WINDOW HAD BECOME INOPERATIVE. THE SERVICE TECH FOUND CORROSION IN SOME WIRES. *SCC *CB *JB
WHILE TRAVELING ON HIGHWAY ABS BRAKING LIGHT AND ALL WHEEL DRIVE LIGHT APPEARED ON DASHBOARD. DEALERSHIP WAS AWARE OF PROBLEM.