7.9% of complaints about the 2001 Dodge Caravan came in the first year, which is unremarkable for a 2001 vehicle — around the middle of the 216 model-years on record. The median complaint arrives at 4.3 yr in service. The most-reported system is air bags (41 complaints), typically at 4.3 yr or about 60,000 miles.
CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.
IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.
EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
THIS COULD RESULT IN A SPEAKER FIRE.
CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.
A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.
AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.
IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2001 PLYMOUTH VOYAGER, CHRYSLER TOWN & COUNTRY, AND DODGE CARAVAN/GRAND CARAVAN MINI VANS THAT ARE NOT EQUIPPED WITH THE REMOTE KEYLESS ENTRY OPTION. THE SLIDING DOOR LATCHES ON THESE VEHICLES COULD RELEASE DURING CERTAIN SEVERE ACCIDENT CONDITIONS THAT INVOLVE THE SLIDING DOOR.
THIS COULD ALLOW THE SLIDING DOOR TO PARTIALLY OPEN.
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
WHILE TRAVELING AT HIGHWAY SPEEDS TRANSMISSION SUDDENLY DIED WITHOUT WARNING. DRIVER FELT LUCKY THAT VEHICLE MADE IT TO THE SIDE OF THE ROAD. *AK
VEHICLE HAS JUMPED OUT OF GEAR WHILE CONSUMER WAS PARKED, AND VEHICLE WAS IN IDLE. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK
VEHICLE SLAMS INTO SECOND GEAR WHILE DRIVING AT ANY SPEED CAUSING CAR TO NOSE DIVE AND ALMOST CAUSING IT TO BE REAR ENDED. INCIDENT OCCURRED 10/15/02, 10/26/02, 11/23/02 AND 04/29/03. VEHICLE IS CURRENTLY AT DEALER AFTER HAVING BEEN "FIXED" THREE TIMES BEFORE THIS. *NLM
AIR BAG READY LIGHT REMAINS ON AT ALL TIMES THE VEHICLES IS OPERATED. DEALER STATE DEFECTIVE CLOCK SPRING THIS PART IS NOT AVAILABLE ON BACK ORDER NO DELIVERY DATE KNOWN. *AK