7.8% of complaints about the 2015 Fiat 500 came in the first year, which is unremarkable for a 2015 vehicle — around the middle of the 195 model-years on record. The median complaint arrives at 3.8 yr in service. The most-reported system is power train (34 complaints), typically at 3.7 yr or about 48,204 miles.
Chrysler (FCA US, LLC) is recalling certain 2014-2019 Fiat 500 vehicles. The tire pressure monitoring system (TPMS) warning light may not illuminate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
A TPMS warning light that fails to illuminate can result in the vehicle being driven with improperly inflated tires, increasing the risk of a crash.
DLT, LLC. is recalling certain CravenSpeed Fiat Short Shifter shafts sold for use in 2011-2019 Fiat 500 vehicles. The Shifter Shaft may have been improperly manufactured with a through hole for the set screw rather than a blind hole, which may lead to the breakage of the Shifter Shaft.
If the shifter breaks while the vehicle is in motion, it can increase the risk of a crash.
Chrysler (FCA US LLC) is recalling certain model year 2012-2016 Fiat 500 vehicles manufactured June 21, 2010, through January 12, 2016, equipped with a manual transmission. The clutch diaphragm spring may fracture and fail, causing an inability to switch gears.
If the clutch diaphragm spring fails, the driver may not be able to shift gears or the vehicle may lose motive power, increasing the risk of a crash.
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Fiat 500 battery electric vehicles manufactured March 8, 2013, to March 7, 2015. The Electric Vehicle Control Unit (EVCU) of the affected vehicles may set a diagnostic trouble code (DTC) that may cause the transmission to unexpectedly shift to neutral.
If the vehicle unexpectedly shifts to neutral, the loss of drive could increase the risk of a crash.
TL* THE CONTACT OWNS A 2015 FIAT 500. AFTER THE VEHICLE WAS STARTED, THE STEERING WHEEL CONTROLS AND SPEEDOMETER BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SYSTEM NEEDED TO BE RESET. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 350.
TL* THE CONTACT OWNS A 2015 FIAT 500. THE CONTACT STATED THAT THE VEHICLE SHIFTED OUT OF DRIVE INTO NEUTRAL WHEN THE ELECTRICAL SYSTEM OVERHEATED. THE CONTACT WAS ABLE TO MOVE ONTO THE ROAD SHOULDER, RESTART THE ENGINE, AND THE VEHICLE RESUMED NORMAL OPERATION AFTER THE ENGINE COOLED DOWN. THE DEALER ADVISED THE CONTACT TO SHIFT THE GEAR INTO NEUTRAL MANUALLY WHEN THE BURNING ODOR EMITTED OR THEY COULD REPROGRAM THE ELECTRICAL SYSTEM; HOWEVER, IT WOULD NOT PERMANENTLY CORRECT THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 17,000.
TL* THE CONTACT OWNS A 2015 FIAT 200C (NA). THE CONTACT EXPERIENCED SEVERAL ELECTRICAL FAILURES WITH THE VOICE RECOGNITION AND RADIO. ALSO, THE VEHICLE SHIFTED FROM DRIVE TO PARK AND THE VEHICLE WAS STILL MOVING EVEN THOUGH THE GEAR SHIFTER STATED IT WAS IN PARK. THE VEHICLE SEIZED IN THE DRIVE POSITION. THE FAILURES OCCURRED BETWEEN THE SPEEDS OF 30 TO 40 MPH. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.
THERE IS A MANUAL TRANSAXLE CLUTCH RECALL THAT CAN CAUSE THE INABILITY TO SHIFT POSSIBLY RESULTING IN LOSS OF POWER. THIS IS A SIGNIFICANT SAFETY ISSUE BUT FIAT HAS NO PARTS AVAILABLE TO FIX THE PROBLEM. AFTER TWO CALLS TO FIAT, THE MOST RECENT ON 9/2/2016, THERE IS NO DATE AVAILABLE FOR PARTS AVAILABILITY AN NOTHING THEY CAN DO TO ADDRESS THE RESULTING SAFETY ISSUE. WE ARE ALL SUPPOSED TO WAIT AND HOPE FOR THE BEST.