10% of complaints about the 2002 Ford E-350 came in the first year, which is unremarkable for a 2002 vehicle — around the middle of the 230 model-years on record. The median complaint arrives at 6.8 yr in service. The most-reported system is engine cooling (17 complaints), typically at 6.7 yr or about 95,000 miles.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
CERTAIN VANS AND WAGONS FAIL TO CONFORM TO THE REQUIREMENTS OF PART 567, "CERTIFICATION." FOR CERTAIN 2003 E250 VANS BUILT WITH LT225/75R16E TIRES, THE REAR AXLE RATING IS INCORRECTLY LISTED ON THE LABEL. IN ADDITION, THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES ON CERTAIN 2002 E350 WAGONS AND FOR THE FRONT TIRES ON CERTAIN 2002 E250 VANS BUILT WITH THESE TIRES.
FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION RECOMMENDATION CAN RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.
FORD E350 5.4L TRINTON ENGINE BLEW OUT SPARK PLUG. IT HAPPENED WHEN I RESUMED DRIVING AFTER STOPPING AT A RED LIGHT. RESEARCHED THIS OUT AND FOUND HUNDREDS AND HUNDREDS OF COMPLAINTS ON THE INTERNET. *JB
TL*THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT AFTER THE DEALER REPLACED THE SPARK PLUGS THE ENGINE SHOT THE SPARK PLUGS OUT OF THE ENGINE BLOCK 15,000 MILES LATER. EVERYTIME THE CONTACT HAS THE PLUGS REPLACED THE VEHICLE CONTINUED TO SHOOT OUT THE SPARK PLUGS. THE CONTACT BROUGHT THE VEHICLE TO THE DEALER, WHO STATED THAT THE ENGINE HEADS NEED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGE WERE 131,000.*AK
2002 FORD E350 AT 39,000 MILES ONE SPARK PLUG BLEW.. OUT OF HEAD. FORD DEALERSHIP SAID THEY WOULD ONLY REPLACE THE ENTIRE HEAD AT A COST OVER $5,000.00 DOLLARS. HAD REPAIRED WITH HELCOIL AT LOCAL REPAIR SHOP. AGAIN AT 79,000 MILES TWO SPARK PLUGS BLEW OUT OF HEAD. NOT YET REPAIRED. *TR