4.9% of complaints about the 2005 Ford Five Hundred came in the first year, which is unremarkable for a 2005 vehicle — around the middle of the 245 model-years on record. The median complaint arrives at 6.5 yr in service. The most-reported system is power train (139 complaints), typically at 6.2 yr or about 73,000 miles.
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
UPON PUTTING THE VEHICLE IN PARK IT WILL PUT ITSELF INTO REVERSE. THIS HAPPENED TWICE. GOING DOWN HILL THE AT 50 MPH THE SPEEDOMETER WILL DROP TO 20 MPH. LOSING TWO TO TWO AND ONE HALF MILES TO A GALLON. CONTACTED THE DEALER. TOOK THE VEHICLE IN. FORD HAD THE VEHICLE FOR FOUR WEEKS. FORD STATED THERE WAS NOTHING WRONG WITH THE VEHICLE. HOWEVER, THE PROBLEM RECURRED. *AK
VEHICHLE CONSTANTLY SHIFTING. "SEARCHES" FOR FOR CORRECT GEAR. HAD COMPUTER REPLACED AND A WEEK LATER REOCCURRED. REPROGRAMMED COMPUTER AGAIN AND REOCCURRED. FORD UNABLE TO REPAIR. LOSING 6-8 MPG.*AK
DT: 2005 FORD 500 SEDAN DID NOT HAVE AN INTERMEDIATE OR SECOND GEAR FOR GEARING DOWN TO GOING DOWN MOUNTAINS. THIS WAS A SAFETY ISSUE, AND NEEDED TO BE BROUGHT TO FORD'S ATTENTION. *AK *NM
UPON PUTTING THE VEHICLE IN PARK IT WILL PUT ITSELF INTO REVERSE. THIS HAPPENED TWICE. GOING DOWN HILL THE AT 50 MPH THE SPEEDOMETER WILL DROP TO 20 MPH. LOSING TWO TO TWO AND ONE HALF MILES TO A GALLON. CONTACTED THE DEALER. TOOK THE VEHICLE IN. FORD HAD THE VEHICLE FOR FOUR WEEKS. FORD STATED THERE WAS NOTHING WRONG WITH THE VEHICLE. HOWEVER, THE PROBLEM RECURRED. *AK