14.2% of complaints about the 2001 Mercury Grand Marquis came in the first year, which is unremarkable for a 2001 vehicle — around the middle of the 216 model-years on record. The median complaint arrives at 4.6 yr in service. The most-reported system is speed control (25 complaints), typically at 3.1 yr or about 50,000 miles.
Dorman Products, Inc. (Dorman) is recalling certain model Dorman Steering Shafts, part number 425-359, Solutions Steering Shafts, part number 7-0359, and OE Solutions Steering Shafts, part number 425-359, manufactured April 17, 2014, to September 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car vehicles. These steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
If the shafts separate during vehicle operation, a loss of steering control would result, increasing the risk of a vehicle crash.
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
VEHICLE DESCRIPTION: MINIVANS AND PASSENGER VEHICLES. A RESTRAINT CONTROL MODULE (RCM) OR A SIDE OR FRONT CRASH SENSOR MAY HAVE BEEN ASSEMBLED WITH ONE OR MORE OF THE SCREWS THAT MOUNT THE CIRCUIT BOARD IN THE HOUSING MISSING. IF SOME OR ALL OF THE SCREWS ARE MISSING, THE PERFORMANCE OF THE OCCUPANT RESTRAINS COULD BE AFFECTED.
IN SOME CASES, LESS THAN THE INTENDED LEVEL OF PROTECTION IN THE EVENT OF A CRASH.
CERTAIN PASSENGER VEHICLES, LIMOUSINES, AND MINI VANS WERE BUILT WITH A NEWLY DESIGNED RESTRAINT CONTROL MODULE (RCM). IN SOME CASES, THE RCM DOES NOT RECOGNIZE CERTAIN SYSTEM FAULTS THAT COULD RESULT IN AN AIR BAG OR SEAT BELT PRE-TENSIONER UNEXPECTEDLY ACTIVATING DURING THE SELF-TEST SEQUENCE AT VEHICLE START-UP.
THIS CONDITION COULD RESULT IN PERSONAL INJURY.
VEHICLE HAS ACCELERATED 3 TIMES WHEN CONSUMER WANTED TO SLOW DOWN. APPLIED BRAKES, BUT WAS NOT ABLE TO SLOW DOWN. FINALLY, HAD TO TAKE VEHICLE OUT OF GEAR TO SLOW DOWN. DEALER CANNOT FIND CAUSE. *AK
WHILE DRIVING AT 10 MPH ENGINE STARTED TO RACE REALLY LOUD, CONSUMER TURNED KEY OFF, AND HIT BRAKES IMMEDIATELY AND STOPPED. CONSUMER TOWED VEHICLE TO DEALER, AND CURRENTLY IT HAS WORKED. *AK THE MOTOR STARTED RACING FOLLOWING A LOUD NOISE, AND WENT OUT OF CONTROL. THE PROBLEM APPEARS TO BE A FACTRY DEFECT. *YH
VEHICLE SUDDENLY ACCELERATED WHEN APPLYING BRAKES TO STOP AT APPROACHING STOP LIGHT, THIS OCCURRED FOR SECOND TIME. VEHICLE TAKEN TO DEALER.ON FIRST OCCASION DEALER WAS UNABLE TO LOCATE CAUSE. ON SECOND OCCASION DEALER REPLACED TRANSMISSION. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION ON THIS MATTER. *AK
TURNING SIGNAL STARTED TO FLASHING REALLY FAST, TOOK VEHICLE TO DEALER AND COULD NOT FIND CAUSE. ENGINEER REPAIRED LIGHTS. CONSUMER STATED THAT SEAT BELT WARNING LIGHT STOPPED WORKING RIGHT AFTER THEY FIXED TURN SIGNAL LIGHT.*AK