10.6% of complaints about the 2000 Pontiac Montana came in the first year, which is unremarkable for a 2000 vehicle — around the middle of the 213 model-years on record. The median complaint arrives at 4.1 yr in service. The most-reported system is engine cooling (68 complaints), typically at 4.3 yr or about 60,000 miles.
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."
IN A VEHICLE ROLLOVER ACCIDENT, IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
PASSENGER SIDE POWER SLIDING DOOR DOES NOT CLOSE ALL THE TIME. IT HAS A FAILURE RATE OF ABOUT 30% OF THE TIME. VEHICLE HAS BEEN BACK TO THE DEALER SIX TIMES, AND NEITHER GM OR DEALER CAN FIX IT. *AK
POWER DOOR WOULD INTERMITTENTLY OR NOT AT ALL OPEN FROM BOTH SIDES. VEHICLE BEEN INTO DEALERSHOP, AND PROBLEM STILL REOCCURRING. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER . *AK
CONSUMER COMPLAINT IS AGAINST DESIGN OF THE POWER SLIDING DOOR. A CHILD WOULD NOT BE CAPABLE OF STOPPING DOOR FROM CLOSING BECAUSE CHILD COULD NOT USE ENOUGH PRESSURE TO STOP DOOR. *CONSUMER DID RECEIVE NOTIFICATION FOR A RECALL, STATING THAT DOOR CAN AUTOMATICALLY OPEN WHILE IN OPERATION. CONSUMER IS TAKING VEHICLE IN FOR REPAIRS. HOWEVER ,THIS IS A SEPARATE ISSUE.*AK THE SLIDING DOOR CLOSES VERY FORCEFULLY AND THE CONSUMER WAS CONCERNED ABLOUT THE POTENTIAL DANGER OF THE DOOR. *YH
WHILE DRIVING 65 ON FREEWAY THE LEFT REAR SLIDING DOOR WINDOW EXPLODED INTO THE CAR. MY DAUGHTER WAS SEATED THERE AND RECEIVED LACERATIONS ON HER LEFT HAND AND ARM. THE GLASS SHOWERED THE ENTIRE INSIDE OF THE VEHICLE WITH GLASS. THE NOISE AS THE WINDOW