12.6% of complaints about the 2003 Saab 9-3 came in the first year, which is unremarkable for a 2003 vehicle — around the middle of the 228 model-years on record. The median complaint arrives at 3.7 yr in service. The most-reported system is electrical system (50 complaints), typically at 3.7 yr or about 60,017 miles.
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
ON CERTAIN PASSENGER VEHICLES, THE ENGINE MANAGEMENT SYSTEM SOFTWARE MAY CAUSE ENGINE HESITATION OR STALLING.
IF THE VEHICLE STALLS AS A RESULT OF THIS CONDITION, IT CAN BE RESTARTED IMMEDIATELY.
SOME SPORT SEDANS WERE BUILT WITH SEAT BELT RETRACTORS THAT WERE DAMAGED DURING THE MANUFACTURING PROCESS. IF DAMAGED, OVER TIME, THE AUTOMATIC TENSIONING SYSTEM (ATS) CABLE IN THE SEAT BELT RETRACTOR COULD BREAK CAUSING THE BELT WEBBING TO NOT RETRACT.
IN THE EVENT OF A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SEVERE INJURIES.
WHILE DRIVING AT 70 MPH, THE VEHICLE STALLED. THE DRIVER RESTARTED THE VEHICLE AND DROVE IT TO THE DEALER FOR ANALYSIS. THE MECHANIC NOTICED THAT ELECTRICAL SYSTEM HAD A SHORTAGE. *PH
SINCE PURCHASING MY 2003 SAAB 9-3 IN JUNE THE CAR HAS STALLED 4 TIMES WHILE EITHER AT STOP LIGHTS OR SITTING IN TRAFFIC. ONCE THE CAR STALLED WHILE GOING 40 MPH. I'VE TAKEN THE CAR TO THE DEALERSHIP SEVERAL TIMES TO HAVE THE PROBLEM CORRECTED. EACH TIME A SOFTWARE UPGRADE IS PERFORMED. AND EVERY TIME I CONTACT THE SERVICE DEPT THEY ARE SURPRISED AS TO THIS OCCURRENCE.*AK
2003 SAFE 9-3 2.0T LINEAR, PURCH NEW 2/21/03 DIES' UNEXPECTEDLY WHEN BEING DRIVEN. FIRST INCIDENT: CAR 'DIED' RIGHT IN THE MIDDLE OF THE ROAD COMPLETELY UNEXPECTEDLY. ASSUMED IT WAS A 'FLUKE' AND TOOK NO ACTION. AFTER SECOND INCIDENT: DEALER "RESET FUEL ADAPTATION VALVE". AFTER THIRD INCIDENT (DANGEROUS - MERGING INTO FREEWAY) DEALER "REPROGRAMMED T8 AND RESET FUEL ADAPTATION PER SAFE TECHNICAL HOT LINE" ALL INCIDENTS OCCURRED WITHIN LAST TWO WEEKS. CAR RESTARTS WITH NO WARNING LIGHT OR "SIDE" INDICATION OF PROBLEM UPON IGNITION. *CB
SAAB 93 - LINEAR - 2003 - AFTER 71 MILES THE ONBOARD COMPUTER SYSTEM DISPLAYED A WARNING LIGHT AND BUZZER - AIR BAG MALFUNCTION - CALL SAAB DEALER. - THIS WAS AFTER 24HOURS OF OWNERSHIP. THE VEHICLE IS PURCHASED.*JB