2003 Saab 9-5

No clear pattern

1.4% of complaints about the 2003 Saab 9-5 arrived in its first year of service. That is an unusual figure for a 2003 vehicle, but with only 69 complaints on record the sample is too small to call it a pattern — the margin of error covers the range where ordinary vehicles sit. The figures below are reported without a verdict. The most-reported system is electrical system (29 complaints), typically at 6.6 yr or about 79,654 miles.

Complaints: 69
Median age at failure: 5.8 yr
Median mileage: 77,800 n=48
Crash / fire / tow: 1.4% of reports
Safety recalls: 4

Safety recalls — NHTSA campaigns

08V160000 2008-04-09

Seats:front assembly:head restraint

SAAB IS RECALLING 57,389 MY 2002-2008 9-5 SERIES VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING COMPLIANCE TESTING, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENTS.

IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.

07V087000 2007-03-07

Fuel system, gasoline:delivery:hoses, lines/piping, and fittings

ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.

OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.

06V410000 2006-10-26

Electrical system:ignition:module

CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.

OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING. ENGINE STALLING MAY OCCUR, WHICH COULD RESULT IN A CRASH.

03V006000 2003-01-13

Wheels:hub

ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATION IS NOT REMOVED, IT IS POSSIBLE THAT AFTER THE TIRE CHANGE SERVICE, SOME OF THIS CONTAMINATION COULD FLAKE OR GRIND AWAY RESULTING IN REDUCED CLAMPING FORCE OF THE WHEEL TO THE HUB. OVER SEVERAL SEASONS, IT IS POSSIBLE THAT THIS REDUCED FORCE COULD RESULT IN FRACTURES DEVELOPING IN THE WHEEL BOLT

THESE FRACTURES WOULD RESULT IN WHEEL BOLT BREAKAGE, ALLOWING THE WHEEL TO DETACH FROM THE WHEEL HUB, INCREASING THE RISK OF A CRASH.

In owners’ own words

Electrical system 100,424 mi 3.4 yr in service

CHECK ENGINE LIGHT ON 2003 SAAB 9-5 AERO DIAGNOSED AS FAILING IGNITION CASSETTE WHICH IS THE SAME FAULTY PART FOR RECALL ON THE 2000-2002 CARS ONLY. A COMPLETE FAILURE WHILE DRIVING WOULD HAVE CAUSED THE ENGINE TO TOTALLY SHUTDOWN. THIS PART WAS REPLACED AT MY COST, BUT THE ORIGINAL PART NUMBER WAS INSTALLED VS. THE NEWER UPGRADED VERSION TO HOPEFULLY PREVENT FUTURE FAILURES. RE: CAMPAIGN ID# 05V399000. SHOULDN'T THE FAULTY "ORIGINAL" PART BE PULLED FROM DEALER STOCK AND WHY HAS THE 2003 MODEL YEAR AND OTHER YEARS BEEN EXCLUDED SINCE THE FAULTY PART IS EXACTLY THE SAME? *NM

Electrical system mileage not reported 3.2 yr in service

SAAB INFORMATION DISPLAY PIXEL FAILURE. THE PIXELS ON THE INFORMATION DISPLAY HAVE BEEN FAILING, AND NOW ARE TO THE POINT WHERE ALMOST UNUSABLE DISPLAY. SAAB SERVICE SAID IT IS A COMMON ISSUE, BUT SINCE THE WARRANTY HAS PASSED, WOULD HAVE TO BUY A NEW DISPLAY UNIT(APPROX. $500) SEARCHING ON THE INTERNET, I HAVE FOUND MANY PEOPLE HAVE THE SAME ISSUE. THERE ARE EVEN SITES SET-UP TO SEND UNIT IN FOR REPAIR.(EX. WWW.SIDREPAIR.COM) *JB

Electrical system mileage not reported 5.4 yr in service

I HAVE BEEN GETTING CONSTANT CHECK ENGINE CODES THAT RELATE TO THE DI CASSETTE. THE DIRECT IGNITION CASSETTE RECALL THAT SAAB HAS INITIALLY CONDUCTED FOR 2000-2002 MODEL 4 CYL CARS NEEDS TO BE EXPANDED TO INCLUDE 2003, AS I HAVE THE SAME PROBLEM WITH THE DI CASSETTE AS SAAB HAS EXPRESSED HAPPENING IN THE 2002 MODELS. I WISH TO HAVE MY DI CASSETTE REPLACED WITHOUT CHARGE AND TO BE INCLUDED IN THE PRE EXISTING RECALL FOR 2002 DRIVERS. *TR

Other 9-5 model years

How to read this

This is what owners reported, not a reliability rating. People file with NHTSA about alarming failures, not routine ones, and complaint volume tracks how many cars were sold.
Failure ages come from the incident date on each complaint, populated on about 83% of records. Mileage is shown where reported — NHTSA’s 2021 system change cut mileage capture to roughly 15%, so it thins out sharply after MY2020.
Every rank compares this vehicle only against others of the same model year. A 2025 car has not had time to accumulate five-year failures, so comparing early-failure share across years is meaningless.
Fourteen make-months distorted by media storms and mass recalls — Toyota in February 2010 ran 11× normal volume across 33 models — are excluded.
Recalls are manufacturer actions and authoritative; complaints are not. A recall listed here may already have been performed on any individual car. Check a specific VIN at nhtsa.gov/recalls.

2003 Saab 9-5

When each system is reported — middle 50% of complaints

Safety recalls — NHTSA campaigns

In owners’ own words

Other 9-5 model years

How to read this