1.9% of complaints about the 2007 Suzuki XL7 came in the first year, which is unremarkable for a 2007 vehicle — around the middle of the 268 model-years on record. The median complaint arrives at 6.7 yr in service. The most-reported system is air bags (31 complaints), typically at 5.4 yr or about 79,000 miles.
American Suzuki is recalling certain model year 2007 XL-7 vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; and manufactured June 13, 2006, through December 22, 2006. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Fuel leakage in the presence of an ignition source may result in a fire.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD.
IN THE EVENT OF A CRASH, THE WINDSHIELD MAY NOT BE RETAINED TO THE EXTENT REQUIRED BY THE STANDARD, INCREASING THE RISK OF PERSONAL INJURIES TO THE VEHICLE OCCUPANTS.
SIDE AIR BAGS DEPLOYED WHILE DRIVING DOWN THE STREET AT APPROXIMATELY 30 MILES AN HOUR. THERE WAS NO IMPACT WITH ANYTHING. NO ROUGH ROAD OR POTHOLES, IT WAS A STRAIGHT STRETCH OF ROAD, ON A 4 LANE ROAD. THE NOISE WAS SO LOUD IT ALMOST MADE ME DEAF. THE FUMES WERE AWFUL. I ALMOST WRECKED TRYING TO PULL OUT OF THE STREET. I DID CALL THE POLICE WHOM WROTE AN INCIDENT REPORT, BECAUSE THEY HAD NEVER SEEN THIS HAPPEN BEFORE. *TR
TRAVELING AT 45-50 MPH ON A FLAT ROAD, CLEAR CONDITIONS. HEARD A LOUD BANG INSIDE VEHICLE, 4 SIDE CURTAIN (ROLLOVER) AIRBAGS DEPLOYED SPONTANEOUSLY. NO IMPACT WITH ANYTHING. HORRIBLE SMELL INSIDE VEHICLE. FELT A BURNING ON MY FOREHEAD. DON'T RECALL PULLING OFF ROAD. *TR
AIRBAG MALFUNCTION. LIGHT DOES NOT ALWAYS INITIATE WHEN THERE IS A PASSENGER IN THE CAR. MY CONCERN IS THAT IF THERE IS AN ACCIDENT THAT THE AIRBAG WILL NOT OPERATE PROPERLY OR AT ALL. *TR
POSSIBLE BAD SOFTWARE ISSUE. FAULTY (GONE BAD) 'VOLTAGE REGULATOR CHIP" THAT CONTROLS VOLTAGE AND ALTERNATOR. WHEN IT MALFUNCTIONS IT CAUSES ENTIRE SYSTEM AND MOTOR TO SHUT DOWN. IF YOU ARE DRIVING IT LOCKS UP TRANSMISSION AND YOU CAN NOT CONTROL CAR. BEEN GOING ON FOR MONTHS. DEALERSHIP JUST JERKING ME AROUND FOR MONTHS. *TR