16.2% of complaints about the 2005 Toyota Avalon came in the first year, which is unremarkable for a 2005 vehicle — around the middle of the 245 model-years on record. The median complaint arrives at 5.3 yr in service. The most-reported system is speed control (47 complaints), typically at 5.2 yr or about 44,145 miles.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEA
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE
THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
ON CERTAIN PASSENGER VEHICLES, THE STEERING YOKE WAS NOT WELDED TO THE STEERING SHAFT. IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY COME OFF FROM THE SHAFT, AND COULD RESULT IN A LOSS OF VEHICLE STEERING CONTROL.
LOSS OF CONTROL OF THE VEHICLE COULD RESULT IN A CRASH.
NOTICING HESITATION AT LOW SPEED GEAR SHIFTING . RESULTS IN NO ACCELERATION INSPITE OF PRESSING THE ACCELERATOR AND AFTER A LAG CAR SUDDENLY RESPONDS. HAD TROUBLE WHILE MERGING FROM THE RAMP ON TO THE HIGHWAY NOW FOR A TOTAL OF THREE TIMES. CONCERNED THAT THIS MAY RESULT IN AN ACCIDENT SPECIALLY WHILE MERGING OR DRIVING AT LOW SPEEDS IN HEAVT TRAFFIC.
DT: THE THROTTLE STUCK TO THE FLOOR, CAUSING THE VEHICLE TO GO FORWARD QUICKLY. WITH A LOT OF EFFORT THE CONSUMER WAS ABLE TO GET THE VEHICLE IN NEUTRAL AND SHUT IT OFF. THIS HAPPENED ON SEPTEMBER 18, 2005. WHEN THE CONSUMER TOOK VEHICLE TO THE DEALER FOR REPAIRS THEY TOLD HIM THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THEY DID NOTHING TO ALTER THE VEHICLE. THE CONSUMER FELT THAT THE VEHICLE WAS UNSAFE TO DRIVE. *AK
DT: THE CONSUMER COMPLAINED ABOUT AN AUTOMATIC TRANSMISSION PROBLEM. WHEN APPLYING PRESSURE TO THE ACCELERATOR PEDAL THE GEAR WOULD NOT ENGAGE. THE VEHICLE DID NOT SHIFT GEARS SMOOTHLY. THE CONSUMER SUSPECTED THAT THERE WAS A PROBLEM WITH THE VEHICLE SPEED CONTROL. THE CONSUMER LOST CONTROL OF THE VEHICLE WHEN ANOTHER VEHICLE PASSED. THE DEALERSHIP INFORMED THE CONSUMER THAT THEY COULD NOT DO ANYTHING BECAUSE THE VEHICLE WAS COMPUTER CONTROLLED. *AK (12/01/05) *SC
I RECENTLY PURCHASED A 2005 TOYOTA LIMITED. THE TRANSMISSION POSES SAFETY PROBLEMS BECAUSE IT IS VERY UNEVEN AND UNPREDICTABLE, SHIFTING WHEN YOU DON'T EXPECT SHIFTING, AT LOWER AND HIGHER SPEEDS AND IN CRUISE CONTROL. (SEE THE ON-LINE DISCUSSION FORUM AT EDMUNDS WEBSITE REGARDING THIS PROBLEM WHICH MANY OWNERS ARE EXPERIENCING.