1.9% of complaints about the 2005 Toyota RAV4 came in the first year, which is unremarkable for a 2005 vehicle — around the middle of the 245 model-years on record. The median complaint arrives at 10.8 yr in service. The most-reported system is air bags (59 complaints), typically at 10.9 yr or about 109,000 miles.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2005 Toyota RAV4 vehicles manufactured May 13, 2003, to October 25, 2005. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propella
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
MY WIFE WAS HIT IN A HEAD ON COLLISION THAT DID OVER $8,000 IN DAMAGE IN THE TOYOTA, 2005 , RAV 4. WITH THIS DAMAGE YOU WOULD THINK ONE AIRBAG WOULD DEPLOY, AND THAT DID NOT HAPPEN.WE ARE VERY CONCERNED ABOUT THIS WHEN GETTING THE CAR BACK OUT OF THE SHOP.TOYOTA AIRBAG TECHNICIAN SAID THEY DIDN'T ALWAYS DEPLOY DEPENDING ON THE IMPACT, WHAT??,HEAD ON WITH OVER $8.000 IN DAMAGE,WHAT WILL IT TAKE SOMEONE TO BE KILLED. *AK
HEAD ON COLLISION, AIRBAGS DID NOT DEPLOY, SEAT BELTS DID NOT LOCK, MAJOR STRUCTURAL DAMAGE TO THE RAV 4 TOYOTA 2005. *TR
TL* THE CONTACT OWNS A 2005 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, ANOTHER VEHICLE CRASHED INTO THE CONTACT. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED BROKEN THUMBS, CUTS ON THE RIGHT HAND, AND INJURIES TO THE SHOULDER AND SPINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 06V096000 (AIR BAGS). THE APPROXIMATELY FAILURE MILEAGE WAS 73,000. UPDATED 5/19/14*CN UPDATED 06/02/2014 *JS