3.6% of complaints about the 2004 Volkswagen Beetle came in the first year, which is unremarkable for a 2004 vehicle — around the middle of the 236 model-years on record. The median complaint arrives at 6.8 yr in service. The most-reported system is power train (157 complaints), typically at 6.9 yr or about 69,760 miles.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the af
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
CONSUMER WAS INVOLVED IN AN ACCIDENT WHERE THE AIR BAGS FAILED TO DEPLOY. THE AIRBAG LIGHT WAS ON, AS WELL AS THE CHECK ENGINE AND ABS LIGHTS. CONSUMER WENT TO DEALERSHIP TO GET VEHICLE SERVICED, BUT DEALERSHIP COULD NOT DETERMINE THE CAUSE OF THE PROBLEM.*AK
BOUGHT NEW 2004 VW BEETLE IN 9/04, 2 WEEKS LATER, AIRBAG LIGHT CAME ON, TOOK TO DEALER. THEY HAD THE CAR OVER 8 WEEKS TRYING TO FIX. FINALLY AGREED TO REPLACE WITH IDENTICAL NEW ONE. LESS THAN 2500 MILES LATER, AIRBAG LIGHT COMES ON AGAIN. THEY RESET BUT DID NOT DO ANY REPAIRS. DON'T KNOW IF THAT FIXED THE PROBLEM AS SHORTLY AFTER, STEERING WENT OUT CAUSING THE VEHICLE TO RUN OFF ROAD AND HIT GUARD RAIL. VW HAS NOW, WAITING TO SEE IF THEY TAKE RESPONSIBILITY, IT DOESN'T APPEAR AS THEY WILL FROM WHAT I AM HEARING FROM SERVICE MANAGER. FINAL VERDICT NOT IN YET.*AK
THE AIR BAG LIGHT STAYED ON. THE CAR HAS BEEN TAKEN BACK FOR THIS PROBLEM ON 5 SEPARATE OCCASIONS. ON ONE OCCASION WE NEVER EVEN LEFT THE DEALERSHIP. THE LAST TIME WE PICKED IT UP THE VEHICLE THEY TOLD US IT WAS A SOFTWARE ISSUE, AND THE SOLUTION SHOULD BE IN TWO WEEKS, AND IT WAS SAFE TO DRIVE. IT HAS BEEN ALMOST FIVE MONTHS AND STILL NO SOLUTION AS OF YET. THEY WERE STILL SAYING TWO WEEKS.*AK
CONSUMER WAS INVOLVED IN AN ACCIDENT WHERE THE AIR BAGS FAILED TO DEPLOY. THE AIRBAG LIGHT WAS ON, AS WELL AS THE CHECK ENGINE AND ABS LIGHTS. CONSUMER WENT TO DEALERSHIP TO GET VEHICLE SERVICED, BUT DEALERSHIP COULD NOT DETERMINE THE CAUSE OF THE PROBLEM.*AK