2004 BMW 7 Series

Typical pattern

5.3% of complaints about the 2004 BMW 7 Series came in the first year, which is unremarkable for a 2004 vehicle — around the middle of the 236 model-years on record. The median complaint arrives at 8.6 yr in service. The most-reported system is power train (29 complaints), typically at 8.3 yr or about 80,071 miles.

Covers 3 variants: 745LI (50), 745I (41), 760I (6)

Complaints: 131
Median age at failure: 8.6 yr
Median mileage: 84,230 n=114
Crash / fire / tow: 13.7% of reports
Safety recalls: 4

Safety recalls — NHTSA campaigns

10V446000 2010-10-01

Service brakes, hydraulic:power assist:vacuum

BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.

POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.

04V575000 2004-12-06

Seats:front assembly:seat heater/cooler

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH FRONT SEAT HEATING SYSTEMS, UPON ENTERING AND EXITING THE VEHICLE, EXCESSIVE CONTACT WITH THE SIDE BOLSTER THAT IS CONTAINED IN THE SEAT'S BACKREST MAY DAMAGE THE HEATING MAT LOCATED IN THIS AREA. IF SUCH DAMAGE WERE TO OCCUR, WITH THE SYSTEM TURNED ON, THE VEHICLE OCCUPANT MAY FEEL EXCESSIVE HEAT FROM THIS AREA.

IT IS POSSIBLE THAT THE HEATING MAT IN THE BACKREST'S SIDE BOLSTER COULD OVERHEAT AND DAMAGE, OR MELT A SMALL HOLE IN, THIS AREA OF THE SEAT COVER. IF THIS HAPPENED, IT COULD LEAD TO AN OCCUPANT BEING BURNED.

04V379000 2004-08-09

Seats

ON CERTAIN PASSENGER VEHICLES, THE SOFTWARE PROGRAMMING OF THE DRIVER'S SEAT OCCUPANT DETECTION SYSTEM (ODS) MAY NOT BE ABLE TO RELIABLY DETERMINE IF THE DRIVER'S SEAT IS OCCUPIED.

IN CERTAIN CRASH CONDITIONS, THE DRIVER'S FRONT AIR BAG, HEAD PROTECTION SYSTEM, SAFETY BELT PRETENSIONER, AND KNEE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF INJURY TO A SEAT OCCUPANT.

04V344000 2004-07-14

Power train:automatic transmission:control module (tcm/pcm/tecm)

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.

AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION. THE VEHICLE MAY NOT BE ABLE TO RESTART. ALSO, A LOSS OF POWER STEERING AND, AFTER REPEATED ACTUATION OF THE BRAKE PEDAL, A LOSS OF BRAKE POWER ASSIST WILL OCCUR. THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH.

In owners’ own words

Power train 2,386 mi 11 mo in service

AFTER TWO WEEKS OF PURCHASE, THE VEHICLE WENT INTO NEUTRAL MODE WITH THE GEAR SHIFT STILL IN DRIVE WITHOUT WARNING. THE CONSUMER COASTED THE VEHICLE TO THE SIDE OF THE ROAD. ON A SEPARATE OCCASION, THE POWER STEERING FAILED AND BECAME DIFFICULT TO OPERATE FOR DIRECTIONAL CONTROL TWICE. ON BOTH ITEMS THE DEALERSHIP WAS UNABLE TO DUPLICATE THE PROBLEM. PLEASE PROVIDE DETAILS. *JB THE CONSUMER WAS TOLD THERE WAS A 9/1/04 RECALL NOTICE TO REPROGRAM THIS MODEL VEHICLE. THE CONSUMER WAS TOLD THAT HIS VEHICLE WAS NOT DURING THIS RECALL PERIOD. *TC

Power train 21,000 mi 1.6 yr in service

VEHICLE BECAME HARD TO CONTROL, AND CONSUMER WAS ABLE TO CONTAIN IT. AFTER COMING TO A FULL STOP REAR DRIVER'S WHEEL CONTINUED TO SPIN. VEHICLE HAD TO BE TOWED, AND NO DEFECTS WERE FOUND.*AK

Power train 51,550 mi 7.5 yr in service

TL*THE CONTACT OWNS A 2004 BMW 760LI. WHILE DRIVING ABOVE 50 MPH, THE CONTACT STATED THAT THE VEHICLE WOULD SHAKE EXCESSIVELY AND THEN STALL WITHOUT WARNING SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 04V344000 (POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM). BOTH THE DEALER AND MANUFACTURER ADVISED THE CONTACT THAT HIS VEHICLE WAS NOT INCLUDED IN THE PREVIOUS RECALL AND OFFERED NO ADDITIONAL ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGES WAS 51,600 AND THE FAILURE MILEAGES WAS 51,550.

Air bags 70,000 mi 4.5 yr in service

SHORTLY AFTER PURCHASE OF A USED 2004 BMW 745LI, THE AIRBAG LIGHT REMAINED ILLUMINATED AND THE PASSENGER OCCUPANCY LIGHT REMAINED ILLUMINATED AT ALL TIMES. CAR WOULD NOT PASS INSPECTION, THEREFORE I PAID $1700 TO BMW OF SILVER SPRING TO HAVE THIS CORRECTED. *TR

Other 7 Series model years

How to read this

This is what owners reported, not a reliability rating. People file with NHTSA about alarming failures, not routine ones, and complaint volume tracks how many cars were sold.
Failure ages come from the incident date on each complaint, populated on about 83% of records. Mileage is shown where reported — NHTSA’s 2021 system change cut mileage capture to roughly 15%, so it thins out sharply after MY2020.
Every rank compares this vehicle only against others of the same model year. A 2025 car has not had time to accumulate five-year failures, so comparing early-failure share across years is meaningless.
Fourteen make-months distorted by media storms and mass recalls — Toyota in February 2010 ran 11× normal volume across 33 models — are excluded.
Recalls are manufacturer actions and authoritative; complaints are not. A recall listed here may already have been performed on any individual car. Check a specific VIN at nhtsa.gov/recalls.

2004 BMW 7 Series

When each system is reported — middle 50% of complaints

Safety recalls — NHTSA campaigns

In owners’ own words

Other 7 Series model years

How to read this