1.8% of complaints about the 2007 Chevrolet Malibu came in the first year, which is unremarkable for a 2007 vehicle — around the middle of the 268 model-years on record. The median complaint arrives at 7.8 yr in service. The most-reported system is steering (673 complaints), typically at 8.3 yr or about 105,000 miles.
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or
Any of the above failure conditions increases the risk of a crash.
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being r
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DT*: THE CONTACT STATED THERE WAS A LOUD KNOCKING NOISE WHEN THE TRANSMISSION WAS SHIFTED INTO DRIVE. ALL OTHER GEARS WERE SMOOTH AND QUIET. THREE SEPARATE SERVICE DEALERS HAD INSPECTED THE VEHICLE AND WERE AWARE OF THE KNOCKING SOUND, BUT INFORMED THE CONTACT THE NOISE WAS COMMON WITH THE VEHICLE AND WOULD DIMINISH WITH TIME. COMPUTER DIAGNOSTICS FOUND NOTHING WRONG. THE MANUFACTURER WAS NOTIFIED. THE CONSUMER COMPLAINED OF A VIBRATION WHEN THE BRAKES WERE APPLIED. THE DEALER RESURFACED THE ROTORS. UPDATED 12/01/06 *JB
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED UPON STARTING THE VEHICLE, THE GEAR HAD TO BE SHIFTED INTO NEUTRAL SO THAT THE VEHICLE WOULD START UP. THE SHIFT LINKAGE MALFUNCTIONED WHICH CAUSED THE INABILITY TO SHIFT GEARS. FURTHERMORE, THE CATALYTIC CONVERTER HAD BEEN REPLACED ON TWO OCCASIONS BUT THE CHECK ENGINE LIGHT REMAINED ILLUMNATED. THE VEHICLE WAS NOT IN DRIVABLE CONDITION AT THE TIME OF THE COMPLAINT. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALERSHIP REGARDING THE SHIFT LINKAGE AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 91,000.
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED UPON STARTING THE VEHICLE, THE GEAR HAD TO BE SHIFTED INTO NEUTRAL SO THAT THE VEHICLE WOULD START UP. THE SHIFT LINKAGE MALFUNCTIONED WHICH CAUSED THE INABILITY TO SHIFT GEARS. FURTHERMORE, THE CATALYTIC CONVERTER HAD BEEN REPLACED ON TWO OCCASIONS BUT THE CHECK ENGINE LIGHT REMAINED ILLUMNATED. THE VEHICLE WAS NOT IN DRIVABLE CONDITION AT THE TIME OF THE COMPLAINT. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALERSHIP REGARDING THE SHIFT LINKAGE AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 91,000.
I AM AN AEROSPACE STRUCTURAL TECHNICIAN NOW RETIRED, AND I HAVE THE FOLLOWING PROBLEM. DRIVERS SEAT FRAME WELD BUSTED DUE TO MATERIALS AND WORKMANSHIP, CAUSING THE SEAT TO ROTATE BACKWARDS AND TO THE RIGHT. CONTACTED CHEVROLET DEALERSHIP AND CHEVROLET CUSTOMER SERVICE. THEY REPLIED, SORRY ABOUT THAT! *AK