1.8% of complaints about the 2004 Chevrolet Monte Carlo came in the first year, which is unremarkable for a 2004 vehicle — around the middle of the 236 model-years on record. The median complaint arrives at 6.1 yr in service. The most-reported system is electrical system (150 complaints), typically at 5.5 yr or about 55,000 miles.
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In the
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
WARPED DASHBOARD IN MY 2004 MONTE CARLO, RADIO FACE ALSO GETS BLISTERING HOT, TRUNK LID OPEN APPEARS ALL THE TIME ON DASH, TOO K TO DEALER, TRUNK LID FIXED NEW DASH INSTALLED 3 DAYS LATER DASH WARPED WORSE THAN BEFORE AND BOTH SIDE PILLARS NOW CRACKED, BRAKES STILL NOISY AND PEDAL TO THE FLOOR, DEALER STATES NORMAL. SCHEDULING FOR MY SECOND DASHBOARD, AND STILL NO ANSWERS ON WHY YOU CANT TOUCH THE RADIO. *NM
SPEEDOMETER STARTED REGISTERING INCORRECT SPEED, THEN WORKED SPORADICALLY AND SOMETIMES NOT AT ALL. CAR WAS TAKEN TO THE DEALERSHIP TO HAVE IT LOOKED AT. THEY DETERMINED THAT THE WHOLE INSTRUMENT PANEL CONSOLE NEEDED TO BE REPLACED (NOT JUST THE SPEEDOMETER). THE DEALERSHIP SENT THE OLD INSTRUMENT PANEL TO THE PARTS SUPPLIER AND RECEIVED A NEW INSTRUMENT PANEL, THEN INSTALLED IT. THEY SPECULATED THAT IT MIGHT HAVE BEEN BECAUSE OF A BAD GROUND IN THE SYSTEM. UNSURE WHETHER OR NOT OLD PART IS AVAILABLE. *JB
THE SPEEDOMTER AND RPM GAUGES WORK IRRATICALLY, AND ARE NOT ACCURATE. THERE WERE NO SIGNS THAT THIS WAS STARTING IT JUST ONE DAY STARTED FOR NO APPARENT REASON. I HAVE SPOKEN TO SERVERAL OWNERS OF THE 2004 CHEVROLET MONTE CARLO'S IN MY AREA, AND ALL HAVE THE SAME PROBLEMS. CHEVROLET NEEDS TO RECALL THESE DASH CLUSTERS. *NM
CLUNKING NOISE FROM THE STEERING COLUMN. SERVICE WRITER TOOK THE INFO & AN HOUR LATER INFORMED ME THAT PROBLEM WAS FIXED AND I OWED $108.00!!!! NO COMMUNICATION, NO ESTIMATE, NO NOTHING BUT THIS CHARGE, EVEN THOUGH I HAVE AN EXTENDED WARRANTY AND GM KNOWS ABOUT THIS PROBLEM. SAID THEY LUBED A NEOPRENE SEAL ON THE INTERMEDIATE SHAFT OF THE STEERING COLUMN. *TR