2023 Ford Bronco Sport

Typical pattern

10.8% of complaints about the 2023 Ford Bronco Sport came in the first year, which is unremarkable for a 2023 vehicle — around the middle of the 177 model-years on record. The median complaint arrives at 2.7 yr in service. The most-reported system is electrical system (37 complaints), typically at 2.1 yr or about 25,000 miles.

Complaints: 223
Median age at failure: 2.7 yr
Median mileage: 25,000 n=58
Crash / fire / tow: 12.1% of reports
Safety recalls: 10 1 do not drive

Safety recalls — NHTSA campaigns

26V340000 2026-05-27 Do not drive

Suspension:front:control arm:lower ball joint

Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.

A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.

25V685000 2025-10-10

Equipment:electrical:engine block heater

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

An electrical short circuit can increase the risk of a fire.

25V467000 2025-07-11

Fuel system, gasoline:fuel injection system

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.

25V442000 2025-06-27

Back over prevention:software

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

25V158000 2025-03-14

Power train:automatic transmission:control module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

25V165000 2025-03-14

Fuel system, gasoline:fuel injection system

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.

A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

25V019000 2025-01-17

Electrical system:12v/24v/48v battery

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.

Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.

24V594000 2024-08-09

Visibility:windshield wiper/washer:motor

Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.

Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.

24V267000 2024-04-12

Electrical system:body control module/bcm

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

24V223000 2024-03-22

Tires

Ford Motor Company (Ford) is recalling certain 2023 Maverick and Bronco Sport vehicles. The tires may have been manufactured incorrectly, which may result in a loss of vehicle handling and control.

A loss of vehicle handling and control increases the risk of a crash.

In owners’ own words

Power train mileage not reported 1.0 yr in service

Fuel pump loose in gas tank. Ocassional smell of fuel in cabin when starting vehicle. RPMs stick at high levels occassionally.

Power train mileage not reported 2.8 yr in service

Recall Action Soon Issue Since 07-18-2025 Fuel injector replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement

Power train mileage not reported 2.9 yr in service

Transmission violently jerks when shifting making it unsafe to even drive. Severe uneven shifting. RPM fluctuations exacerbate the problem ( since a normal automatic transmission will naturally shift upon acceleration at specific intervals, but not this one). Also would not shift into Park or reverse. We finally had to have it towed to the shop. This is a 2023 Ford Bronco sport and should be recalled. The transmission is a severely flawed and unsafe design.

Engine 250 mi 10 mo in service

The contact owns a 2023 Ford Bronco Sport. The contact stated while driving 25 MPH, the contact heard an abnormal sound coming from the vehicle. No warning light was illuminated. The vehicle was diagnosed by a dealer and confirmed that the engine and turbo charger was blown, and oil was coming out of the exhaust. The vehicle was not repaired due to parts not being available. The manufacturer was made aware of the failure and was unable to estimate time of arrival for parts. The failure mileage was approximately 250.

Other Bronco Sport model years

How to read this

This is what owners reported, not a reliability rating. People file with NHTSA about alarming failures, not routine ones, and complaint volume tracks how many cars were sold.
Failure ages come from the incident date on each complaint, populated on about 83% of records. Mileage is shown where reported — NHTSA’s 2021 system change cut mileage capture to roughly 15%, so it thins out sharply after MY2020.
Every rank compares this vehicle only against others of the same model year. A 2025 car has not had time to accumulate five-year failures, so comparing early-failure share across years is meaningless.
Fourteen make-months distorted by media storms and mass recalls — Toyota in February 2010 ran 11× normal volume across 33 models — are excluded.
Recalls are manufacturer actions and authoritative; complaints are not. A recall listed here may already have been performed on any individual car. Check a specific VIN at nhtsa.gov/recalls.

2023 Ford Bronco Sport

When each system is reported — middle 50% of complaints

Safety recalls — NHTSA campaigns

In owners’ own words

Other Bronco Sport model years

How to read this