8.1% of complaints about the 2012 Ford Explorer came in the first year, which is unremarkable for a 2012 vehicle — around the middle of the 201 model-years on record. The median complaint arrives at 7.0 yr in service. The most-reported system is steering (359 complaints), typically at 8.3 yr or about 95,000 miles.
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. These vehicles may be equipped with a cross-axis ball joint (CABJ) replacement part that could seize, and result in a fracture of the outboard section of the rear suspension toe link.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
Ford Motor Company (Ford) is recalling certain replacement steering gears installed on model year 2011-2012 Explorers as service parts in September 2013 and January 2014. The affected gears may lock, preventing the driver from being able to steer the vehicle.
The inability to steer the vehicle increases the risk of a crash.
POWER STEERING FAULT WHILE RETURNING FROM SHORT SUPERMARKET TRIP, LOST ALL POWER STEERING, DASH BOARD LIT UP, THEN TERRAIN SENSOR FAULT, CAUSING A FEELING OF REDUCED GEAR, TURN SIGNALS FAILED AS WELL. VERY DIFFICULT TO DRIVE, AND UNABLE TO RESET BY SHUTTING VEHICLE OFF. DEALERSHIP STATED A FAULT IN POWER STEERING RACK, REQUIRING REPLACEMENT, THEY ALSO STATED IT IS A DIFFERENT PART NUMBER THEN ORIGINAL PART MEANING IT MAY HAVE BEEN REMODELED DUE TO "ISSUES". VERY DANGEROUS SITUATION!!!! *TR
FORD SYNC SYSTEM - CONTINUES TO FREEZE AND NOT FUNCTION. NAVIGATION SYSTEM FREEZES UP AND/OR DOESN'T WORK AT TIMES. PHONE SYSTEM SHOWS YOU ON A CALL WHEN YOU ARE NOT. MULTIPLE TIMES NOT WORKING AND IS SUPPOSED TO BE HANDS FREE. HAVE HAD THE SYSTEM REPLACED AND UPDATED AND STILL DOESN'T WORK PROPERLY OR AS ADVERTISED. FORD CASE # CAS [XXX] KEEP GETTING TOLD THEY HAVE AN EXPERT LOOKING IN TO IT AND IT MIGHT BE RELATED TO THE IPHONE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT WAS DRIVING 50 MPH WHEN THE ADVANCE TRACKING WARNING LAMP ILLUMINATED AND THE POWER STEERING FAILED. THE VEHICLE WAS TAKEN THE DEALER FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE ELECTRONIC POWER ASSISTANCE SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 37,000. *TR
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE STOPPED AT A STOP SIGN, THE CONTACT DEPRESSED THE ACCELERATOR PEDAL AND NOTICED THAT THE PEDAL BECAME STUCK IN A DEPRESSED POSITION. THE VEHICLE THEN ACCELERATED ON ITS OWN. THE CONTACT DEPRESSED THE BRAKE PEDAL AND WAS ABLE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 6,000.