3.6% of complaints about the 2008 Ford F-250 came in the first year, which is unremarkable for a 2008 vehicle — around the middle of the 262 model-years on record. The median complaint arrives at 7.8 yr in service. The most-reported system is steering (80 complaints), typically at 8.1 yr or about 77,600 miles.
CONTINENTAL TIRE IS RECALLING CERTAIN CONTITRAC TR TIRES, SIZE LT275/70R18 125/122S OUTLINE WHITE LETTERS AND BLACK SIDEWALL, AND CONTITRAC, SIZE LT275/70R18 125/122S, BLACK SIDEWALL, PRODUCED FROM MAY 6, 2007, THROUGH SEPTEMBER 20, 2008, SOLD AS AFTERMARKET AND INSTALLED AS ORIGINAL EQUIPMENT ON SOME MODEL YEAR 2008 AND 2009 FORD F-250 AND F-350 TRUCKS. SOME OF THESE TIRES MAY EXPERIENCE UNEVEN WEAR, VIBRATION, OR PARTICULARLY UNDER CONDITIONS OF OVERLOADING OR UNDER INFLATION IN HIGH AMBIENT TEMPERATURE USAGE, SEPARATION BETWEEN THE BELT EDGES.
SEPARATION OF THE BELT EDGES COULD LEAD TO TREAD BELT SEPARATION, INCREASING THE RISK OF A CRASH.
FORD IS RECALLING 64,754 MY 2008 F-250 AND F-350 SINGLE REAR WHEEL, 4X4, 156 INCH WHEEL BASE PICK UP TRUCKS EQUIPPED WITH A TWO PIECE DRIVE SHAFT FOR FAILING TO CONFORM TO THE FUEL SPILLAGE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." DURING A 30 MPH FRONTAL IMPACT INTO A RIGID BARRIER, THE FUEL TANK CAN MOVE FORWARD AND CONTACT A FRAME CROSS MEMBER, POTENTIALLY CAUSING DAMAGE TO THE FUEL DELIVERY MODULE WHICH CAN RESULT IN FUEL SPILLAGE.
FUEL SPILLAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
FORD IS RECALLING 87,515 MY 2008 F250, F-350, F-450, AND F-550 VEHICLES FOR FAILING TO COMPLY WITH ALL THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." SOME 40% SPLIT AND CAPTAIN'S CHAIR DRIVER'S SEATS, EQUIPPED WITH LUMBAR SUPPORTS, MAY HAVE IMPROPER WELDS AT THE JOINT OF THE SEAT BACK PIVOT BRACKET AND THE SEAT BACK FRAME.
IN THE EVENT OF A CRASH, THE SEAT SIDE PIVOT BRACKET MAY CRACK OR BREAK, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS SPECIFIED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE DRIVER AIR BAG MODULE MAY NOT HAVE BEEN PROPERLY ASSEMBLED.
THIS CONDITION MAY PREVENT THE DRIVER AIR BAG FROM PROPERLY DEPLOYING AND REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.
LACK OF POWER OR ROUGH OPERATION, UNUSUAL NOISES FROM THE ENGINE OR EXHAUST, WHITE SMOKE FROM THE EXHAUST, AND POTENTIALLY A VISIBLE FLAME OUT THE TAILPIPE CAN OCCUR.
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, INSUFFICIENT CLEARANCE OF THE BATTERY POSITIVE (B+) WIRE TO THE RIGHT HAND SPLASH SHIELD BOLT MAY RESULT IN THE BATTERY B+ WIRE CONTACTING THE SPLASH SHIELD BOLT.
LONG TERM CONTACT COULD CAUSE WIRE CHAFE, RESULTING IN COPPER WIRE BEING EXPOSED. IF THIS CONDITION OCCURS, THE BATTERY B+ WIRE COULD SHORT TO GROUND INCREASING THE RISK OF A FIRE.
TL*THE CONTACT OWNS A 2008 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE LOST ALL POWER, BRAKE, AND STEERING ABILITY. THE DEALER REPLACED THE POWER STEERING PUMP AT THE CONTACT'S EXPENSE. THE DEALER STATED THAT THEY WERE AWARE OF THE FAILURES, BUT COULD NOT PROVIDE A REMEDY. THE FAILURE HAS OCCURRED INTERMITTENTLY APPROXIMATELY 100 TIMES. THE FAILURE MILEAGE WAS 300 AND CURRENT MILEAGE WAS 60,000. UPDATED 06/08/09 *BF THE CONSUMER STATED THE VEHICLE NOW HAS A POWER STEERING FLUID LEAK. UPDATED 06/18/09.*JB
TL* THE CONTACT OWNS A 2008 FORD F250. WHILE DRIVING APPROXIMATELY 30-40 MPH, THERE WAS A COMPLETE LOSS OF POWER STEERING. THE CONTACT WAS UNABLE TO GAIN CONTROL OF THE VEHICLE AND CRASHED INTO THE GUARDRAIL. A POLICE REPORT WAS FILED WITH NO PERSONAL INJURIES. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY INFORMED THE CONTACT THAT THE FAILURE WAS RELATED TO THE STEERING BOX. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 55,000.
TL* THE CONTACT OWNS A 2008 FORD F-250 SUPRERDUTY DIESEL. THE CONTACT STATED THAT THE VEHICLE BECAME VERY DIFFICULT TO STEER WHILE DRIVING 30 MPH. THE CONTACT INSPECTED THE VEHICLE AND THOUGHT THAT THE FAILURE INVOVLED THE STEERING BOX AND SHAFT. THE VEHICLE HAD NOT BEEN TAKEN TO THE TO THE DEALER, BUT THE MANUFACTURER HAD BEEN NOTIFIED. THE FAILURE MILEAGE WAS 36,000. UPDATED 6/4/12 *CN
TL*THE CONTACT OWNS A 2008 FORD F-250. THE VEHICLE HAS FOUR CONTINENTAL TIRES. THE CONTACT STATED THAT THREE OF THE TIRES WERE LEAKING AIR. THE REMAINING TIRE HAS NINE HOLES INSIDE THE THREAD AND THE CONTACT HAS TO PLACE AIR IN IT EVERYDAY. THE MANUFACTURER DOES NOT WANT TO REPLACE THE TIRES. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT FORD WOULD NOT HONOR THE REPAIR. THE TIRE LINE AND SIZE WERE UNKNOWN. THE FAILURE MILEAGE WAS 3,000 AND CURRENT MILEAGE WAS 8,000.