17.4% of complaints about the 2000 Ford F-550 SD came in the first year, which is unremarkable for a 2000 vehicle — around the middle of the 213 model-years on record. The median complaint arrives at 2.8 yr in service. The most-reported system is tires (24 complaints), typically at 2.0 yr or about 17,956 miles.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.
IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHIC
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
VEHICLE DESCRIPTION: TRUCKS EQUIPPED WITH COMMERCIAL TRUCK TIRES THAT HAVE STEEL CORDS IN THE TIRE SIDEWALL. THE VALVE STEMS MAY HAVE BEEN TORN OR DAMAGED DURING ASSEMBLY AND COULD LEAK CAUSING SIDEWALL DAMAGE.
IF NOT MAINTAINED, COULD RESULT IN A SIDEWALL ZIPPER FAILURE. A ZIPPER FAILURE DURING INFLATION OF A DAMAGED TIRE COULD RESULT IN INJURY TO SOMEONE NEAR THE TIRE.
WHILE PULLING A TRAILER AT 50 MPH WITH DRIVER & ONE PASSENGER, NOTICED A FLAPPING NOISE FROM REAR INNER TIRE. ENTIRE SIDEWALL HAS COLLAPSED ON A 2000, FORD F550 , ORIGINAL EQUIPMENT, LMT460; DOT# CU9R1HTR389. TIRE AVAILABLE FOR ANALYSIS. *AK
THE TREAD OF THE TIRE SEPARATED FROM THE SIDEWALLS. IT WAS THE INSIDE TIRE OF A DUAL WHEEL SETUP. *AK( DOT NUMBER: CU9PHMTJ TIRE SIZE: 2257OR19.5 )
DEALER WILL ONLY REPLACE VALVE STEMS, NOT LEAKING TIRES AS STATED IN RECALL. FORD SAYS IT'S UP TO DEALER. VEHICLE HAS HAD 3 BLOWOUTS ON MAY 2 AND 3 , 2001; 1 RIGHT FRONT, AND 2 REAR TIRES, AFTER VALVE STEMS WERE REPLACED. *AK