5.9% of complaints about the 2006 Jeep Wrangler came in the first year, which is unremarkable for a 2006 vehicle — around the middle of the 250 model-years on record. The median complaint arrives at 5.0 yr in service. The most-reported system is fuel system (358 complaints), typically at 4.9 yr or about 36,000 miles.
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
If the vehicle unexpectedly moves there is an increased risk of a crash.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCE, AND ENGINE STALLING COULD OCCUR WHICH COULD RESULT IN A CRASH.
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
WHEN TRYING TO LEAVE A PARKING LOT FROM A DEAD STOP I DEPRESS THE CLUTCH AND BRAKE PEDALS, STARTED THE ENGINE, AND PLACE THE TRANSMISSION IN REVERSE. AS SOON AS I LOOKED BACK THE CLUTCH PEDAL WENT TO THE FLOOR AND THE JEEP LEAPT BACKWARDS. APPARENTLY THE "PLASTIC" LINKAGE CONNECTING THE PEDAL TO THE CLUTCH MECHANISM SNAPPED. IT IS NOW BEING REPLACED BUT FROM PREVIOUS REPORTS I BELIEVE THIS WILL BECOME A COMMON PROBLEM FOR THE 6 SPEED TRANSMISSION ON THE 2006 JEEP WRANGLER. *JB
NEW JEEP WRANGLER WITH 6-SPEED MANUAL TRANSMISSION GRINDS WHEN OPERATOR UPSHIFTS FROM 1ST TO 2ND GEARS, NECESSITATING AN UNUSUALLY SLOW SHIFT AND CONSEQUENT POOR LOW-SPEED ACCELERATION FROM A STOP. CONDITION IS WORSE WHEN VEHICLE IS COLD AND INTERMITTENT WHEN WARM. TOOK VEHICLE TO DEALERSHIP FOR WARRANTY REPAIRS. JEEP REPRESENTATIVES STATE CONDITION IS "NORMAL" FOR THIS VEHICLE. NO REPAIR PERFORMED. *JB
MODEL: 2006 JEEP WRANGLER RUBICON WITH 6 SPEED TRANSMISSION. AFTER BACKING OUT OF A PARKING STALL AND DURING THE TRANSITION FROM REVERSE TO 1ST GEAR THE CLUTCH PEDAL LOST ITS CONNECTION TO THE CLUTCH MECHANISM. THE PEDAL WAS FREE TO SWING WITH NO RESISTANCE AT ALL. THERE WAS A LOUD "POP" FROM UNDER THE DASH. I WAS ABLE TO DRIVE THE VEHICLE TO THE DEALERSHIP BY BY-PASSING THE CLUTCH INTERLOCK SWITCH AND STARTING THE VEHICLE IN GEAR. THE VEHICLE HAD EXACTLY 74 MILES ON THE ODOMETER. THE DEALERSHIP REPAIRED THE VEHICLE UNDER WARRANTY. *NM
WHEN VEHICLE IS MOVING AND WINDOWS ARE OPENED, A TOXIC NOXIOUS ODOR IS EMITTED INTO THE VEHICLE. PROBLEM STARTED WHEN VEHICLE WAS PICKED UP NEW FROM DEALER. OCCUPANTS OF VEHICLE ARE ABLE TO TASTE A CHEMICAL LIKE SUBSTANCE ON LIPS AND TONGUE. ALSO HEADACHE & DIZZINESS OCCURS WITH CASES OF VOMITING. DEALER REPLACED RADIATOR, COMPRESSOR, VENTS AND ENTIRE EXHAUST SYSTEM AND PROBLEM STILL EXISTS. *JB