5.7% of complaints about the 2002 Mazda MPV came in the first year, which is unremarkable for a 2002 vehicle — around the middle of the 230 model-years on record. The median complaint arrives at 5.6 yr in service. The most-reported system is power train (65 complaints), typically at 5.9 yr or about 67,000 miles.
ON CERTAIN MINIVANS EQUIPPED WITH CRUISE CONTROL, THE CRUISE CONTROL ACTUATOR CABLE MAY BE BROKEN DUE TO INSUFFICIENT STRENGTH (GROUP 1). ALSO INCLUDED ARE CERTAIN 2000-2001 MINIVANS EQUIPPED WITH CRUISE CONTROL BUILT BETWEEN MARCH 31, 1999 AND MARCH 31, 2001, THAT HAVE HAD THE CRUISE CONTROL REPAIRED AND POSSIBLY HAD A DEFECTIVE CABLE INSTALLED DURING THAT REPAIR (GROUP 2).
IT IS POSSIBLE THAT THE BROKEN ACTUATOR CABLE MAY BE OUT OF POSITION AND COULD INTERFERE WITH THE OPERATION OF THE ACCELERATOR CABLE, PREVENTING A DECREASE IN ENGINE SPEED WHILE DRIVING, INCREASING THE RISK OF A CRASH.
ON CERTAIN MINI VANS AND PASSENGER VEHICLES, THE SOCKET HOLDER IN THE FOG LIGHTS IS INSTALLED IN THE LAMP CASING USING PRESSURE. DURING OPERATION OF THE FOG LIGHT, THE HEAT FROM THE BULB CAN EXPAND THE SOCKET HOLDER. THE EXPANSION CAN FORCE THE SOCKET HOLDER REARWARD. AFTER REPEATEDLY BEING SUBJECT TO THIS EXPANSION, IF THE FOG LIGHT IS ALSO SUBJECTED TO VIBRATION DURING VEHICLE OPERATION, THE SOCKET HOLDER WITH THE BULB HOLDER AND THE WIRING HARNESS MAY SEPARATE FROM THE FOG LIGHT CASING.
SHOULD THIS OCCUR, THE BULB SOCKET AND THE HARNESS CAN DROP INSIDE THE BUMPER AND POSSIBLY BUT RARELY, THE HEAT GENERATED BY THE BULB CAN CAUSE THE BUMPER TO BURN.
ON CERTAIN MINI VANS EQUIPPED WITH FRONT FOG LIGHTS,THE FOG LIGHT BULB SOCKET MAY HAVE BEEN INSTALLED IMPROPERLY.
IF THE VEHICLE CONTINUES TO BE USED WITH THIS CONDITION, THE BULB SOCKET AND THE WIRING HARNESS MAY SEPARATE FROM THE FOG LIGHT HOUSING IF EXPOSED TO SHOCK AND/OR VIBRATION AND DROP INSIDE THE BUMPER. SHOULD THIS OCCUR, THE OPERATION OF THE FOG LIGHT MAY THEN CAUSE THE BUMPER TO BURN.
CERTAIN MINI VANS FAIL TO COMPLY TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." AN INCORRECT GROSS AXLE WEIGHT RATING (GAWR) WAS INDICATED ON THE CERTIFICATION LABEL.
WHILE COMING TO A RED LIGHT AND APPLYING BRAKES VEHICLES ENGINE DIED. CAUSE UNKNOWN. *AK CONSUMER CLAIMS THIS IS A FACTORY DEFECT. MAZDA OFFERED CONSUMER AN EXTENDED WARRANTY. *JG
CONSUMER NOTICED A "ROTTEN EGG" ODOR IN CABIN. DEALER HAS NOT BEEN ABLE TO DETERMINE CAUSE. THE MANUFACTURER SENT CONSUMER A LETTER STATING THAT SEVERAL MODELS EXHIBIT THE ODOR. CONSUMER BELIEVES VEHICLE HAS AN EXHAUST LEAK INTO CABIN WHICH INCLUDES CARBON MONOXIDE. CONSUMER HAS EXHIBITED SYMPTOMS OF BREATHING THOSE PARTICULAR FUMES. PH
THE EXHAUST SYSTEM RELEASED A BAD ODOR.*JB THE DEALER AND MANUFACTURER RECOMMENDED THE CONSUMER CHANGE THE TYPE OF GAS WHICH WAS BEING USED, HOWEVER THE ODOR STILL EXISTED. *JB
WHEN SHIFTING THE INDICATOR WILL INTERMITTANTLY NOT SHOW WHAT GEAR VEHICLE IS IN. OVERDRIVE LIGHT WILL BEGIN TO BLINK. VEHICLE HAS BEEN AT DEALER FOR A TOTAL OF 9 DAYS FOR TESTING. PROBLEM IS NOT REMEDIED. NLM