16.3% of complaints about the 2003 Mitsubishi Outlander came in the first year, which is unremarkable for a 2003 vehicle — around the middle of the 228 model-years on record. The median complaint arrives at 5.2 yr in service. The most-reported system is suspension (27 complaints), typically at 10.5 yr or about 82,000 miles.
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross me
A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.
OVERHEATING OF THE TRAILER HITCH WIRING HARNESS MODULE COULD RESULT IN A FIRE.
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER'S MANUAL DOES NOT CONTAIN A STEP-BY-STEP DESCRIPTION FOR HEADREST ADJUSTMENT WHEN INSTALLING A CHILD RESTRAINT SYSTEM (CRS) TETHER STRAP.
IF THE TETHER STRAP IS IMPROPERLY INSTALLED TO THE TETHER ANCHOR, THE CHILD SAFETY SEAT MAY NOT BE SUFFICIENT RESTRAINED. IN THE EVENT OF A CRASH, THE CHILD COULD BE INJURED.
ON CERTAIN SPORT UTILITY VEHICLES, WATER COULD ENTER THE FRONT FLOORBOARD AREA FROM OPENINGS IN THE SIDE SILL OR UPPER DASH AREA. THIS WATER COULD COLLECT UNDER THE SEAT AND CAUSE ELECTRICAL CORROSION TO OCCUR IN THE HARNESS CONNECTORS THAT CONTAIN THE WIRING FOR THE SEAT BELT PRE-TENSIONER, SIDE AIR BAG IMPACT SENSOR, AND STOP LAMPS.
ELECTRICAL CORROSION OF THE HARNESS COULD CAUSE THE SEAT BELT PRE-TENSIONER TO MALFUNCTION, THE SIDE AIR BAG NOT TO DEPLOY AND/OR THE BRAKE LAMPS NOT TO ILLUMINATE OR TO FALSELY ILLUMINATE.
ON CERTAIN SPORT UTILITY VEHICLES, DURING EXTREMELY LOW TEMPERATURE CONDITIONS, ICE CAN BUILD UP INSIDE THE ENGINE THROTTLE VALVE. THIS ICE BUILD-UP COULD CAUSE THE ACCELERATOR PEDAL TO STICK OR NOT TO RETURN TO IDLE AFTER ACCELERATING.
FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
WHILE DRIVING THE VEHICLE SUDDENLY VEERED TO THE RIGHT WHICH WAS FOLLOWED BY A LOUD NOISE. THE DEALER HAS BEEN NOTIFIED. *NLM
STEERING/SUSPENSION OUTLANDER XLS CAR PULLS AND DRIFTS TO THE RIGHT, CAR HAS BEEN TO AUTO SERVICE 3 TIMES AND PROBLEM STILL EXIST. *AK
THE VEHICLE VEERED TO THE RIGHT WHEN DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS BUT THE VEHICLE CONTINUED TO VEER TO THE RIGHT. *AK
CONSUMER CANNOT UNLOCK THE FRONT AND REAR DOORS FROM THE INSIDE OR OUTSIDE OF THE VEHICLE. WATER WENT UNDER FLOOR AND CORRODED THE ELECTRICAL SYSTEM. THIS PROBLEM WAS SIMILAR TO NHTSA RECALL 03V194000: ON CERTAIN SPORT UTILITY VEHICLES, WATER COULD ENTER THE FRONT FLOORBOARD AREA FROM OPENINGS IN THE SIDE SILL OR UPPER DASH AREA. THIS WATER COULD COLLECT UNDER THE SEAT AND CAUSE ELECTRICAL CORROSION TO OCCUR IN THE HARNESS CONNECTORS THAT CONTAIN THE WIRING FOR THE SEAT BELT RETACTOR, SIDE AIR BAG IMPACT SENSOR, AND STOP LAMPS. *AK