4.8% of complaints about the 1999 Plymouth Grand Voyager came in the first year, which is unremarkable for a 1999 vehicle — around the middle of the 201 model-years on record. The median complaint arrives at 5.1 yr in service. The most-reported system is air bags (48 complaints), typically at 5.3 yr or about 72,005 miles.
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
WHILE DRIVING VEHICLE HIT A BUMP AND THE GEARS JUMPED FROM DRIVE INTO NEUTRAL. THE VEHICLE HAS TO BE PUT BACK INTO DRIVE. DEALER HAS NOT SEEN. *AK
WHEN VEHICLE IS IN PARK WITH MOTOR RUNNING, CONSUMER CAN PUT VEHICLE INTO DIFFERENT GEARS AND THE VEHICLE WILL START TO MOVE. MANUFACTURER IS AWARE OF PROBLEM. *AK
WHILE VEHICLE WAS IN PARK POSITION A CHILD WAS ABLE TO PUT VAN INTO DRIVE AND IT TOOK OFF. CHILD WAS WAS NOT TOUCHING THE BRAKES. *AK
HAVE SPENT FOUR MONTHS GOING THROUGH REPAIRS ETC FOR PROBLEM THEY ADMIT EXISTS, AND THEY CAN'T FIX. WE WERE OFFERED A NEW VAN 8/12/99, CORPORATE TOLD THEM TO REPLACE VAN SAME DAY, AND THEY WON'T! WE WENT TTHROUGH CO'S A G AND THE MTR VEHLCE LIC BOARD, WHO TOLD US TO START CIVIL ACTION, AS DID THEIR OWN ARBITRATION CASE ADMINSTR. SINCE IT A NONREPAIRABLE ISSUE WHY CAN'T THEY BE FORCED TO TELL CONSUMERS? *AK