2015 Volvo S60

No clear pattern

1.2% of complaints about the 2015 Volvo S60 arrived in its first year of service. That is an unusual figure for a 2015 vehicle, but with only 81 complaints on record the sample is too small to call it a pattern — the margin of error covers the range where ordinary vehicles sit. The figures below are reported without a verdict. The most-reported system is engine (22 complaints), typically at 6.6 yr or about 76,000 miles.

Complaints: 81
Median age at failure: 5.5 yr
Median mileage: 50,000 n=55
Crash / fire / tow: 13.6% of reports
Safety recalls: 2

Safety recalls — NHTSA campaigns

20V378000 2020-06-30

Seat belts:front

Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.

An unsecured occupant has an increased risk of injury in the event of a crash.

19V849000 2019-11-26

Latches/locks/linkages:doors:latch

Volvo Car of USA LLC (Volvo) is recalling certain 2011-2017 S60, S60I, V60, S60CC and V60CC vehicles. A component within the door latches may break, making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.

A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.

In owners’ own words

Engine 49,999 mi 4.1 yr in service crash / fire / tow

TL* THE CONTACT OWNS A 2015 VOLVO S60. WHILE THE VEHICLE WAS STOPPED AT A TRAFFIC LIGHT, IT STALLED WITHOUT WARNING. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO SUBARU OF MELBOURNE (LOCATED AT 4340 W NEW HAVEN AVE, WEST MELBOURNE, FL 32904, (321) 768-8020) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STARTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 49,999.

Engine 50,000 mi 4.8 yr in service crash / fire / tow

THE ENGINE COMPARTMENT WAS DESTROYED BY A FIRE. THE CAR WAS PARKED AND UNOCCUPIED WHEN A DOORMAN NOTICED THE PROBLEM AND CALLED THE FIRE DEPARTMENT. SFFD EXTINGUISHED THE FIRE.

Engine 115,000 mi 5.3 yr in service

WHILE DRIVING, COMPUTER SCREENS ALL WENT BLACK AND ENGINE SHUT DOWN. IF IT HAD HAPPENED 1 MILE PRIOR, WOULD HAVE BEEN GOING 50-55 ON A CURVY TWO LANE ROAD AND WOULD HAVE RESULTED IN SERIOUS INJURY OR DEATH. TOWED TO DEALER AWAITING RESULTS.

Other S60 model years

How to read this

This is what owners reported, not a reliability rating. People file with NHTSA about alarming failures, not routine ones, and complaint volume tracks how many cars were sold.
Failure ages come from the incident date on each complaint, populated on about 83% of records. Mileage is shown where reported — NHTSA’s 2021 system change cut mileage capture to roughly 15%, so it thins out sharply after MY2020.
Every rank compares this vehicle only against others of the same model year. A 2025 car has not had time to accumulate five-year failures, so comparing early-failure share across years is meaningless.
Fourteen make-months distorted by media storms and mass recalls — Toyota in February 2010 ran 11× normal volume across 33 models — are excluded.
Recalls are manufacturer actions and authoritative; complaints are not. A recall listed here may already have been performed on any individual car. Check a specific VIN at nhtsa.gov/recalls.

2015 Volvo S60

When each system is reported — middle 50% of complaints

Safety recalls — NHTSA campaigns

In owners’ own words

Other S60 model years

How to read this