3.5% of complaints about the 2002 Volvo V70 came in the first year, which is unremarkable for a 2002 vehicle — around the middle of the 230 model-years on record. The median complaint arrives at 9.4 yr in service. The most-reported system is power train (17 complaints), typically at 8.5 yr or about 97,000 miles.
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
ON CERTAIN SPORT UTILITY VEHICLES, THE REAR LEFT AND RIGHT BRAKE LIGHT RELAYS MAY NOT FUNCTION WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY STAY ON CONTINUOUSLY. THE HIGH POSITIONED BRAKE LIGHT AND ALL OTHER TAIL LIGHTS WILL NOT BE AFFECTED.
IF THE BRAKE LIGHTS FAIL TO COME ON, THERE WILL BE NO LOWER BRAKE LIGHTS TO INDICATE TO FOLLOWING VEHICLES THAT THE VEHICLE IS DECELERATING, WHICH COULD RESULT IN A CRASH.
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
THREE TIMES DURING THE MONTH OF AUGUST VEHICLE VIOLENTLY JUMPED FORWARD INTO TRAFFIC. DEALER SAID THERE WAS A PROBLEM WITH A VALVE IN THE TRANSMISSION. *AK WINDOWS SQUEAK WHEN ROLLED DOWN. STEERING WHEEL BOOT WAS NOT IN PLACE.*TS
WHILE DRIVING AT 50 MPH FRONT DRIVER'S SIDE WHEEL SEPARATED FROM THE VEHICLE. WHEN THE WHEEL SEPARATED THE AIR BAGS DEPLOYED. CONSUMER LOST CONTROL OF THE VEHICLE AND COLLIDED WITH ANOTHER VEHICLE. THE POLICE ARRIVED AND CITED THE CONSUMER. VEHICLE WAS EXAMINED BY A CERTIFIED MECHANIC, WHO INFORMED THE CONSUMER THAT THE SHAFT BROKE, CAUSING THE WHEEL TO COME OFF, AND THE COLLISION TO OCCUR. *AK
TL*THE CONTACT OWNS A 2002 VOLVO V70. WHILE DRIVING 35 MPH, THE VEHICLE SPUTTERED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE DID NOT LOSE POWER. THE VOLVO DEALER DIAGNOSED THE VEHICLE AS NEEDING THE ELECTRONIC THROTTLE MODULE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 78,000.