7.1% of complaints about the 2004 Volvo V70 came in the first year, which is unremarkable for a 2004 vehicle — around the middle of the 236 model-years on record. The median complaint arrives at 7.3 yr in service. The most-reported system is engine cooling (23 complaints), typically at 6.9 yr or about 84,000 miles.
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PRESSURE SENSOR LOCATED ON THE LEFT END OF THE FUEL RAIL MAY, AT TIMES, TRANSMIT INCORRECT SIGNAL REGARDING THE FUEL PRESSURE TO THE ENGINE CONTROL MODULE. IF THE SIGNAL IS OUTSIDE OF THE PRE-PROGRAMMED ALLOWABLE LIMITS, A DIAGNOSTIC TROUBLE CODE MAY BE SET AND THE CHECK ENGINE LIGHT WILL COME ON. THE SOLDERED JOINTS ON THE CIRCUIT BOARD OF THE FUEL PRESSURE SENSOR MAY CRACK DUE TO TEMPERATURE CHANGES AND EXCESSIVE VIBRATIONS.
MISFIRE MAY OCCUR DURING DRIVING THAT, IN TURN, WILL REDUCE THE ENGINE TORQUE AND IN THE WORST CASE SCENARIO, THE ENGINE MAY STALL WITHOUT WARNING. IN CERTAIN TRAFFIC SITUATIONS THIS COULD CAUSE AN UNSAFE SITUATION AND POSSIBLY A CRASH.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
ON CERTAIN PASSENGER VEHICLES, THE FRONT CONTROL ARMS MAY NOT HAVE BEEN MANUFACTURED CORRECTLY AND, AS A RESULT, THE STUD AND NUT THAT SECURE THE ARM TO THE SPINDLE MAY LOSE THEIR INITIAL AXIAL TENSION. UNDER CERTAIN DRIVING CONDITIONS, THE STEERING MAY BECOME LESS RESPONSIVE AND THE DRIVER MAY EXPERIENCE STEERING WHEEL PLAY.
THIS DRIVING CONDITION COULD EVENTUALLY LEAD TO SEPARATION BETWEEN THE FRONT CONTROL ARM AND THE SPINDLE, WHICH COULD RESULT IN A CRASH.
2000 V70XCAW CROSS COUNTRY WAGON ETM SYSTEM FAILED. *TS THE AC HOSE COMPRESSOR CONDENSER WAS REPLACED. THE VEHICLE WAS LEAKING GAS AND THE O-RING SEAL ON THE PUMP SENDER WAS REPLACED. THE FRONT PASSENGER WINDOW WAS INOPERABLE WHEN TRYING TO USE THE MASTER CONTROLS. THE DEALER REPLACED THE MODULE SWITCH. THE ENGINE WOULD WHINE AT HIGHWAY SPEEDS WHILE ACCELERATING. THE BATTERY, OIL PAN, UPPER TORQUE MOUNT, ANGLE GEAR, ROTORS, FUEL PUMP, FUEL TANK, FUEL SEAL AND STRUTS WERE ALL REPLACED. THE CV BOOT WAS LEAKING. THE TURBO CHARGER WAS REPLACED BECAUSE OF AN OIL LEAK. *JB
2000 V70XCAW CROSS COUNTRY WAGON ETM SYSTEM FAILED. *TS THE AC HOSE COMPRESSOR CONDENSER WAS REPLACED. THE VEHICLE WAS LEAKING GAS AND THE O-RING SEAL ON THE PUMP SENDER WAS REPLACED. THE FRONT PASSENGER WINDOW WAS INOPERABLE WHEN TRYING TO USE THE MASTER CONTROLS. THE DEALER REPLACED THE MODULE SWITCH. THE ENGINE WOULD WHINE AT HIGHWAY SPEEDS WHILE ACCELERATING. THE BATTERY, OIL PAN, UPPER TORQUE MOUNT, ANGLE GEAR, ROTORS, FUEL PUMP, FUEL TANK, FUEL SEAL AND STRUTS WERE ALL REPLACED. THE CV BOOT WAS LEAKING. THE TURBO CHARGER WAS REPLACED BECAUSE OF AN OIL LEAK. *JB
TL*THE CONTACT OWNS A 2004 VOLVO V70. THE CHECK ENGINE LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSIS LOCATED THE FAILURE AS THE FUEL PRESSURE SENSOR. THE MANUFACTURER STATED THAT THE VIN WASN'T LISTED IN RECALL 07V226000 ENGINE AND ENGINE COOLING; THEREFORE, THEY WOULD NOT ASSIST WITH THE REPAIRS. THE FAILURE AND THE CURRENT MILEAGES WERE 84,000. UPDATED 01/13/11*LJ UPDATED 03/31/11 UPDATED 05/04/11 *BF UPDATED 08/19/11*JB