2000 Chevrolet Silverado 3500

Typical pattern

20.2% of complaints about the 2000 Chevrolet Silverado 3500 came in the first year, which is unremarkable for a 2000 vehicle — around the middle of the 213 model-years on record. The median complaint arrives at 3.8 yr in service. The most-reported system is service brakes, hydraulic (30 complaints), typically at 2.9 yr or about 58,000 miles.

Complaints: 89
Median age at failure: 3.8 yr
Median mileage: 56,000 n=44
Crash / fire / tow: 10.1% of reports
Safety recalls: 1

Safety recalls — NHTSA campaigns

06E043000 2006-05-19

Fuel system

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

In owners’ own words

Service brakes, hydraulic mileage not reported 6 mo in service

HAPPENED TO BE TURNING AROUND IN A PARKING LOT, PULLED OUT INTO THE HIGHWAY WITH BUMPER TO BUMPER TRAFFIC, FELT POWER STEERING JUMP. THEN, THERE WAS NO POWER STEERING OR BRAKES, EVEN AT A LOW SPEED 5MPH. THE ONLY WAY TO STOP VEHICLE WAS WITH THE EMERGENCY BRAKES. *AK *ML

Service brakes, hydraulic mileage not reported 1.3 yr in service

BACK BRAKES DO NOT WORK PROPERLY, FRONT TIRES WERE REPLACED DUE TO FAULTY RIGHT FRONT BRAKES, CONSUMER STATES THAT THERE HAVE BEEN MANY CLOSE CALLS DUE TO THE FAULTY BRAKES. *SLC

Service brakes, hydraulic mileage not reported 1.3 yr in service crash / fire / tow

WHEN APPLYING BRAKES AT 30MPH PEDAL WENT TO FLOOR ,RESULTING IN EXTENDED STOPPING DISTANCE, AND CAUSING A COLLISION AND INJURY. DEALER AND MANUFACTURER HAS BEEN NOTIFIED.*AK

Tires mileage not reported 11 mo in service

GENERAL AMERI 550 TR TIRES(245 75R 16) EXPERIENCED PEELING AND BUBBLING ON SIDEWALL. *SLC

Other Silverado 3500 model years

How to read this

This is what owners reported, not a reliability rating. People file with NHTSA about alarming failures, not routine ones, and complaint volume tracks how many cars were sold.
Failure ages come from the incident date on each complaint, populated on about 83% of records. Mileage is shown where reported — NHTSA’s 2021 system change cut mileage capture to roughly 15%, so it thins out sharply after MY2020.
Every rank compares this vehicle only against others of the same model year. A 2025 car has not had time to accumulate five-year failures, so comparing early-failure share across years is meaningless.
Fourteen make-months distorted by media storms and mass recalls — Toyota in February 2010 ran 11× normal volume across 33 models — are excluded.
Recalls are manufacturer actions and authoritative; complaints are not. A recall listed here may already have been performed on any individual car. Check a specific VIN at nhtsa.gov/recalls.

2000 Chevrolet Silverado 3500

When each system is reported — middle 50% of complaints

Safety recalls — NHTSA campaigns

In owners’ own words

Other Silverado 3500 model years

How to read this