2000 Ford F-250 SD
No clear pattern 1.5% of complaints about the 2000 Ford F-250 SD arrived in its first year of service. That is an unusual figure for a 2000 vehicle, but with only 263 complaints on record the sample is too small to call it a pattern — the margin of error covers the range where ordinary vehicles sit. The figures below are reported without a verdict. The most-reported system is engine cooling (71 complaints), typically at 7.2 yr or about 99,450 miles.
- Complaints
- 263
- Median age at failure
- 6.7 yr
- Median mileage
- 77,228 n=214
- Crash / fire / tow
- 18.6% of reports
- Safety recalls
- 4
09V399000 2009-10-13
Speed control
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
07E106000 2007-12-17
Wheels:hub
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
07V553000 2007-12-05
Engine and engine cooling:engine:diesel
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.
IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.
06E026000 2006-03-23
Exterior lighting
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Speed control mileage not reported 1.0 yr in service
THE VEHICLE WAS DELIVERED FROM THE FACTORY WITH POOR WIRING SYSTEM WHICH CAUSED THE CRUISE CONTROL TO BE OUT OF SERVICE ON TWO OCCASIONS. *MJS
Speed control 128,000 mi 5.2 yr in service crash / fire / tow
PARKED VEHICLE ABOUT AND 25 MINUTES LATER SMOKE WAS COMING FROM UNDER THE HOOD OF THE VEHICLE. OPENED THE HOOD TO FIND THE CRUISE CONTROL SERVO WAS SMOKING. DISCONNECTED THE WIRES TO THE SERVO AND IT STOPPED. HAAD THE BURNED PART FOR INSPECTION. DURING THE TRIP BEFORE THE FIRE THE CRUISE CONTROL LIGHT ON THE DASHBOARD WAS COMING ON AND OFF AND WAS NOT USED. *AK THE CONSUMER STATED THAT THE CANCEL SWITCH WAS LEAKING. *TC
Speed control 209,000 mi 5.8 yr in service
MY 2000 F-250 SUPER DUTY HAD THE FAULTY CRUISE CONTROL DEACTIVATION BURN UP. THE F150 HAS THE RECALL BUT NOT THE 250, EVEN THOUGH ITS THE SAME FAULTY PART ON BOTH VEHICLES. THERE WAS A LOT OF SMOKE, BUT NO VISIBLE FLAMES. I WAS ABLE THE UNPLUG THE DEVICE BEFORE ANY MAJOR DAMAGE HAPPENED. *NM
Engine cooling mileage not reported 3.5 yr in service
FORD SUPER DUTY DIESEL F-250 : ENGINE CUTS OUT AND/OR DIES DURING ALL LOAD CONDITIONS. ESPECIALLY DANGEROUS WHEN PASSING CARS OR ON FREEWAY. DEALER IS UNABLE TO LOCATE PROBLEM AND "NOTHING REGISTERS ON THE COMPUTER" BEGAN IN MARCH 2003 AND CONTINUES DAILY TO THIS DAY.