8% of complaints about the 2003 Nissan Frontier came in the first year, which is unremarkable for a 2003 vehicle — around the middle of the 228 model-years on record. The median complaint arrives at 6.3 yr in service. The most-reported system is fuel system (15 complaints), typically at 6.5 yr or about 89,000 miles.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.
THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.
IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A V6 ENGINE, AN INCORRECT SIZE WHEEL RIM FOR THE SPARE TIRE WAS PROVIDED IN THESE VEHICLES. THE WHEEL RIM DOES NOT FIT PROPERLY AS A REPLACEMENT FOR A FRONT WHEEL.
WHEN INSTALLED ON THE FRONT OF THE VEHICLE, THE WHEEL RIM WILL CONTACT THE BRAKE CALIPER CAUSING A LOUD RUBBING NOISE AND COULD RESULT IN WEAR ON THE CALIPER AND/OR WHEEL RIM IF DRIVING CONTINUES. CONTINUED USAGE OF THE SPARE TIRE WHEEL AT THE FRONT LOCATION CAN ALSO RESULT IN LOOSENING OF THE LUG NUTS AND DETERIORATION IN BRAKING PERFORMANCE. THIS COULD EVENTUALLY CAUSE THE WHEEL ASSEMBLY TO SE
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.
THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.
I RECEIVED A RECALL LETTER CONCERNING AN INSTALLATION OF A FUEL TANK PROTECTOR. I SPOKE WITH THE CONSUMER AFFAIRS OFFICE ABOUT A REIMBURSEMENT OF THE COST TO REPLACE THE TANK (AS NOTED IN THE RECALL LETTER). I FAXED ALL REQUESTED INFORMATION TO NISSAN, BUT HAVE NOT RECEIVED A REIMBURSEMENT. *NM
SERVICE ENGINE SOON LIGHT CAME ON AND I BEGAN TO SMELL GASOLINE. GAS TANK ROTTED OUT AROUND FUEL SENDING UNIT GASKET. FUEL SENDING UNIT AND GAS TANK REPLACED. I DO NOT HAVE THE OLD GAS TANK BUT I DID PHOTOGRAPH IT DIGITALLY. *TR I UNDERSTAND THERE WAS A RECALL FOR NEARLY 500,000 OF THESE VEHICLES BUT DEALER REPORTED MINE WAS NOT COVERED UNDER RECALL.
SERVICE ENGINE SOON LIGHT CAME ON AND I BEGAN TO SMELL GASOLINE. GAS TANK ROTTED OUT AROUND FUEL SENDING UNIT GASKET. FUEL SENDING UNIT AND GAS TANK REPLACED. I DO NOT HAVE THE OLD GAS TANK BUT I DID PHOTOGRAPH IT DIGITALLY. *TR I UNDERSTAND THERE WAS A RECALL FOR NEARLY 500,000 OF THESE VEHICLES BUT DEALER REPORTED MINE WAS NOT COVERED UNDER RECALL.