1.5% of complaints about the 2005 Nissan Frontier came in the first year, which is unremarkable for a 2005 vehicle — around the middle of the 245 model-years on record. The median complaint arrives at 8.4 yr in service. The most-reported system is power train (263 complaints), typically at 8.8 yr or about 102,000 miles.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
NISSAN IS RECALLING CERTAIN FRONT AND REAR LOWER LINKS, P/NOS. 54501ZQ00A, 54500ZQ00A, 551A1ZQ00A, 551A0ZQ00A , 54501EA00A, 54500EA00A, 551A1EA500, 551A0EA500, 54501ZR00A, AND 54500ZR00A, SOLD BETWEEN NOVEMBER 25, 2009 AND MAY 14, 2010 AS REPLACEMENT PARTS FOR MODEL YEAR 2004 THROUGH 2010 TITAN, ARMADA, AND QX56, AND MODEL YEARS 2005 THROUGH 2010 FRONTIER, XTERRA, AND PATHFINDER VEHICLES. THE LOWER CONTROL LINK ASSEMBLY HAS TWO CYLINDRICAL COLLARS FORMING THE INBOARD ATTACHMENT POINTS TO THE CHASSIS. DUE TO AN IMPROPER WELDING PROCESS SOME COLLARS MAY CONTAIN WELDS THAT DO NOT MEET STRENGTH
IF THE COLLAR WELD SEPARATES, THE VEHICLE HANDLING WILL DETERIORATE, POSSIBLY RESULTING IN A VEHICLE CRASH.
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY
THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
CERTAIN HOPKINS AFTERMARKET TRAILER BRAKE CONTROL CONNECTION HARNESSES SOLD FOR USE ON CERTAIN MODELS OF NISSAN VEHICLES WHICH ARE LISTED ABOVE. THE INTERNAL PART NUMBERS WITHIN HOPKINS ARE: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, AND 1290376035. A WIRE MAY HAVE BEEN PLACED IN AN INCORRECT POSITION IN THE ELECTRICAL CONNECTOR HOUSING. THIS RESULTS IN AN INCORRECT ROUTING OF WIRES BETWEEN THE TRAILER BRAKE CONTROLLER AND THE TOWING VEHICLE WIRING SYSTEM.
THIS HARNESS WOULD RESULT IN POWER FROM THE TRAILER BRAKE CONTROLLER GOING TO THE TOWING VEHICLE DASH LIGHT CIRCUIT RATHER THAN THE TRAILER BRAKES. THIS RESULT WOULD BE THE LACK OF TRAILER BRAKING WHEN THE TOWING VEHICLE BRAKES WERE APPLIED. IT WOULD ALSO RESULT IN THE TOWING VEHICLES DASH LIGHTS BEING ACTIVATED WHEN THE VEHICLE BRAKES WERE APPLIED. THE FAILURE OF THE APPLICATION OF THE TRAILER
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.
THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
THE "DIFFERENTIAL LOCK" (DIF LOCK) DASH LIGHT GOES ON AFTER A PERIOD OF DRIVING. AFTER AWHILE, THE DIF LOCK LIGHT TURNS OFF & THE ABS & SLIP DASH LIGHTS COME ON. AT FIRST, THE DEALER COULD NOT REPRODUCE THE PROBLEM. AFTER ADDITIONAL DRIVING BY THE DEALERSHIP, THE LIGHTS CAME ON. THE DEALERSHIP REPLACED A CONTROL MODULE WHICH CONTROLS ALL OF THESE FEATURES.
THE DRIVE-SHAFT PULLEY BROKE WHICH BROKE A BELT THAT DISABLED POWER-STEERING AND ALMOST CAUSED AN ACCIDENT WHEN STEERING BECAME VERY DIFFICULT. *NM THERE'S ALSO A PROBLEM WITH THE HOOD LATCH LOOSENING THAT MAY CAUSE THE HOOD TO FLY OPEN AT HIGH SPEEDS.
I HAD TO HAVE EMERGENCY SERVICE TO THE U-JOINTS. STRONG VIBRATION UNDER DRIVER SEAT, AFRAID TO DRIVE ANY FURTHER. PERUZZI NISSAN REFUSING TO REIMBURSE A WARRANTY PART. *TR
I PUCHASED A 05 FRONTIER P/U 2WD, AND LOG ON 2K MILES WHEN ENGINE CHECK SOON LIGHT CAME ON. I BROUGHT TO THE DEALER AND THEY ORDERED A CATALETIC CONVERTER ON 5-19-05 BUT UNTILL NOW THEY DONT HAVE THE PART AND TOLD ME TO CALL NISSAN FACTORY INQUIRING ABOUT MY CATALETIC CONVERTER? I BELIEVE THE DEALERSHIP SHOULD FOLLOW-UP OR TRACK WHEN IS THE PART COMING, I DONT GET ANY ANSWER EXCEPT THAT THE P/U IS NEW AND HARD TO GET THE PARTS IN. SHOULD I GET A REPLACEMENT CAR IN THE MEANTIME WHILE THEY HAVE TO WAIT FOR THE PARTS TO COME IN? REGARDS ROGER FEROLINO