1% of complaints about the 2005 Volvo XC90 came in the first year, which is unremarkable for a 2005 vehicle — around the middle of the 245 model-years on record. The median complaint arrives at 7.1 yr in service. The most-reported system is power train (64 complaints), typically at 5.5 yr or about 71,000 miles.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
MISPLACEMENT OF THE JACK'S CRANK HANDLE CAN POSE A SAFETY RISK AS IT CAN RESULT IN A SHORT CIRCUIT OF THE BATTERY WHICH COULD THEN LEAD TO A FIRE.
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
THE HEATER PIPES THAT GO THROUGH THE FIREWALL HAVE CORRODED IN LESS THAN 2 YEARS AND NORTH POINT VOLVO WANTS A $1,000.00 TO TAKE OF THE DASH AND REPLACE THIS PART ON THE HEATER WHICH IN AND OF ITSELF IS ONLY A $40.00 PART. THIS PIPE SHOULD NOT BE DEFECTIVE ON A CAR THAT'S LESS THAN TWO YEARS OLD. POOR QUALITY!!!!!!!!!! *TR
TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE BEARINGS THAT WERE INSTALLED ARE STEEL. THE BEARINGS HAVE DETERIORATED BECAUSE THEY ARE NOT GREASED.. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. HE WAS ADVISED THAT THE ENGINE NEEDED TO BE REPLACED AT AN EXPENSE OF $16,000. THE MANUFACTURER HAS NOT BEEN CONTACTED. THE FAILURE MILEAGE WAS 67,000.
TL*THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING 45 MPH, HE HEARD A LOUD NOISE. HE SHUT THE ENGINE OFF AND HAD THE VEHICLE TOWED TO A MECHANIC. HE WAS TOLD BY THE MECHANIC THAT THE REAR BEARING NEEDED TO BE REPLACED BECAUSE THERE WAS NO OIL GETTING TO THE BEARING (BY DESIGN). HE CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY COULD NOT ASSIST HIM. THE VEHICLE WAS BEING REPAIRED WHEN THE COMPLAINT WAS FILED. THE CURRENT MILEAGE WAS 76,431. THE FAILURE MILEAGE WAS APPROXIMATELY 76,380.
I WAS DRIVING MY 2005 VOLVO XC90 AWD A FROM MY HOME TO WORK(ABOUT 20 MILES) WHEN I WAS PARKING THE CAR ON A PARKING LOT, I NOTICED SMOKE COMING FROM UNDER THE HOOD. THE NEXT MOMENT I SAW A LITTLE FIRE COMING FROM UNDER THE HOOD. I STOPPED THE CAR AND GOT OUT. THE FIRE WAS GETTING BIGGER AND BIGGER. I IMMEDIATELY CALLED 911. BY THE TIME THE FIRE ENGINE ARRIVED THE CAR WAS IN FLAMES, AND THE FRONT WINDSHIELD CRACKED AND FELL INSIDE THE CAR. THE FRONT SEATS AND MY PERSONAL PROPERTY WERE BURNED. *JB