2.9% of complaints about the 2003 GMC Sierra 1500 came in the first year, which is unremarkable for a 2003 vehicle — around the middle of the 228 model-years on record. The median complaint arrives at 8.0 yr in service. The most-reported system is service brakes (55 complaints), typically at 11.8 yr or about 90,000 miles.
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
CERTAIN FEDERAL-MOGUL NATIONAL AND CARQUEST AFTERMARKET HUB ASSEMBLIES, P/N 515058, SOLD FOR USE ON 2001-2006 GENERAL MOTORS 1500 AND 2500 4WD TRUCKS. ON THE SUBJECT HUB ASSEMBLIES, THE ABS SENSOR CORD DEPARTS FROM THE HUB ASSEMBLY AT A 90 DEGREE ANGLE. AS A RESULT, THERE IS A FIT ISSUE WITH THE BRAKE ROTOR DUST SHIELD INTERFERING WITH THE ABS SENSOR CORD. IF THE HUB ASSEMBLY IS INSTALLED DESPITE THIS INTERFERENCE, THE GAP BETWEEN THE ABS SENSOR AND THE TONE WHEEL MAY BE ALTERED. THIS MAY WEAKEN THE OUTPUT OF THE ABS SENSOR. DIMINISHED OUTPUT COULD RESULT IN AN UNWANTED ABS ACTIVATION AT
IF STOPPING DISTANCE IS LIMITED, A VEHICLE CRASH COULD OCCUR.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.
DT*: THE CONTACT STATED THAT WHILE DRIVING 15 MPH AND MAKING A RIGHT TURN, THERE WAS A CLUNKING NOISE UNDER THE HOOD, AND A SHAKING IN THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER REMOVED THE SHAFT SECTOR, REGREASED IT, AND REINSTALLED IT.
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS ON ANY ROAD CONDITIONS, WHENEVER THE VEHICLE HIT A BUMP IN THE ROAD THERE WAS A KNOCKING NOISE IN THE STEERING GEAR BOX. THE NOISE GOT LOUDER WHEN THE STEERING WHEEL WAS TURNED TO EITHER DIRECTION. THE VEHICLE WAS NOT TAKEN IN FOR SERVICE.
I HAVE A 2003 GMC SIERRA EXT CAB SHORT BED PICKUP. AT 24,000 MILES I HAD TO HAVE THE STEERING SHAFT REPLACED BECAUSE IT WAS WORE OUT AND CAUSING A POPPING NOISE WHEN I TURNED OR WENT OVER A BUMP. I NOW HAVE 44,000 MILES ON THE TRUCK AND THE SHAFT IS ALREADY WORN OUT AGAIN! IT SEEMS LIKE THESE ARE ONLY LASTING FOR ABOUT 20,000 MILES. *JB
DT*: THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING UNWARRANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THE VEHICLE IS REGISTERED IN MICHIGAN. THE VEHICLE WAS TAKEN TO THE DEALER ON 12/15/06 WHO DETERMINED THAT THE VEHICLE COULD BE REPAIRED AT COST. THERE IS A NHTSA RECALL #05V379000, REGARDING THE SERVICE BRAKES, HYDRAULIC: ANTILOCK. THE VIN WAS NOT INCLUDED IN THE RECALL.