8.4% of complaints about the 2002 Chevrolet Tahoe came in the first year, which is unremarkable for a 2002 vehicle — around the middle of the 230 model-years on record. The median complaint arrives at 6.8 yr in service. The most-reported system is service brakes (90 complaints), typically at 12.3 yr or about 137,000 miles.
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH REARWARD FOLDING HEAD RESTRAINTS ON THE SECOND ROW SEATS, TWO POTENTIAL PINCH POINTS EXIST ON EACH OF THE FOLDING HEAD RESTRAINTS WHEN THE RESTRAINTS ARE FOLDED REARWARD AS THE SEATBACK IS FOLDED DOWN.
IF A PERSON WERE TO INSERT THEIR FINGER(S) INTO THE PINCH POINT WHEN THE HEAD RESTRAINT FOLDS, IT COULD TRAP AND PINCH THE FINGER(S) CAUSING INJURY.
TIRE BLEWOUT ON STRAIGHT SECTION OF HIGHWAY, TREAD STARTED TO SEPARATE.*AK (DOT NUMBER: 8X72 WL2 TIRESIZE: P265/70R16)
A BLISTER IS FORMING ON THE SIDEWALL OF THE FRONT/RIGHT FIRESTONE TIRE, SIZE: P265/70R16, DOT: UNKNOWN. TIRE HAS APPROXIMATELY 300 MILES ON IT, AND IS ORIGINAL EQUIPMENT ON 2002, CHEVROLET TRUCK, TAHOE.*AK CONSUMER STATED THE DOT# 8X72WL24301, THE DEALER REPLACED ALL 5 TIRES.*SLC
WHILE DRIVING RIGHT REAR TIRE SEPARATED FROM SIDEWALL WHICH TORE TIRE FROM RIM, DAMAGING RIM. DEALER CONTACTED. ORIGINAL EQUIPMENT FOR A 2002, CHEVROLET, TAHOE, WILDERNESS LE TIRE SIZE P26570R16. *AKCONSUMER'S FIRST INDICATION SOMETHING WAS WRONG WAS A PRONOUNCED VIBRATION FELT IN THE STEERING. *JG
TRANSMISSION TAKES 30 SECONDS TO SHIFT TO SECOND GEAR. VEHICLE HAS BEEN TAKEN TO DEALER TWICE, CANNOT REMEDY THE PROBLEM.*AK AFTER THE SECOND ATTEMPT, THE TRANSMISSION WAS REPLACED. THE VEHICLE STILL MAKES NOISES AS IF THE TRANSMISSION WAS NOT ADJUSTED CORRECTLY. THE VEHICLE ALSO DOESN'T RUN THE SAME. IT FEELS AS IF THE VEHICLE LOSES POWER. THERE IS A SCRAPING NOISE THAT IS HEARD FROM THE REAR WHEELS. THE BRAKES WERE REPLACED AND THE ROTORS DEGLAZED. *JG