4.9% of complaints about the 2004 Chevrolet Tahoe came in the first year, which is unremarkable for a 2004 vehicle — around the middle of the 236 model-years on record. The median complaint arrives at 5.2 yr in service. The most-reported system is electrical system (215 complaints), typically at 4.0 yr or about 68,000 miles.
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE S
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
WHILE DRIVING 60 MPH THE VEHICLE'S RPMS REVVED UP. THE VEHICLE WOULD NOT ACCELERATE ANY HIGHER THAT 15 MPH. THE DEALER INSPECTED THE VEHICLE THEN DRAINED THEN DRAINED THE TRANSMISSION FLUID. THE DEALER INDICATED THAT THEY NEEDED TO REPLACE THE TRANSMISSION. THEY DIDN'T INDICATE WHY THEY WERE REPLACING THE TRANSMISSION OR WHAT CAUSED THE FAILURE. *AK *NM
TRANSMISSION DOES NOT ALWAYS DOWNDHIFT INTO FIRST GEAR WHEN COMING TO A COMPLETE STOP AND DOWNSHIFTS INTO FIRST HARD AFTER ACCELERATION OF VEHICLE SPEED INCREASES DO TO SECOND GEAR NOT MOVING VEHICLE. ALSO, WHEN SHIFTER LEVER IS MANUALLY PLACED IN FIRST GEAR TRANMISSION DOES NOT REMAIN IN FIRST, WILL AUTOMATICALLY UPSHIFT INTO SECOND GEAR CAUSING TOWING CONDITIONS TO BECOME HARDER.*AK
I BOUGHT MY TAHOE NEW IN SEPT. 2004. TWO DAYS AFTER PURCHASING TOOK BACK TO DEALER SHIP WITH VIBRATION IN BRAKE PEDAL. THE DEALER SHIP SAID THEY COULD NOT FIX IT THAT IT WAS AN ENGINEERING PROBLEM AND I SHOULD KNOW SOMETHING WITHIN 4-6 WEEKS. WELL IT IS NOW THE END OF JAN. AND I STILL HAVE NOT HEARD WHAT THE FIX WOULD BE AND THE VIBRATION IS GETTING WORSE AND NOW YOU CAN FEEL IT WHEN THE VEHICLE IS SITTING STILL AND IN PARK WITH OUT YOUR FOOT ON THE BRAKE. *NM
LOSS OF MOST STEERING AND SERVICE BRAKES SIMULTANEOUSLY. STEERING FLUID LOSS DUE TO IMPROPERLY INSTALLED STEERING FLUID HOSE CLAMP. AN ASSEMLY CLIP WAS LEFT ON THE HOSE CLAMP AT THE FACTORY WHICH PREVENTED HOSE CLAMP FROM TIGHTENING. THE SIMULTANEOUS LOSS OF MOST STEERING AND BRAKING WOULD HAVE CAUSED SERIOS ACCIDENT IF EVENT HAD OCCURED ON MOUNTAINOUS ROAD OR IF VEHICLE WAS OPERATED BY PERSON WITH LESS STRENGTH. NO WARNING LIGHT OR INDICATION ON DRIVER INFORMATION CENTER APPEARED. SHOULD NOT THESE TWO CRITICAL SYSTEMS FUNCTION INDEPENDANTLY? *AK