2015 Ford Flex
No clear pattern 0.8% of complaints about the 2015 Ford Flex arrived in its first year of service. That is an unusual figure for a 2015 vehicle, but with only 125 complaints on record the sample is too small to call it a pattern — the margin of error covers the range where ordinary vehicles sit. The figures below are reported without a verdict. The most-reported system is back over prevention (25 complaints), typically at 10.3 yr or about 100,000 miles.
- Complaints
- 125
- Median age at failure
- 6.0 yr
- Median mileage
- 52,235 n=81
- Crash / fire / tow
- 8% of reports
- Safety recalls
- 4
25V695000 2025-10-13
Back over prevention: sensing system: camera
Ford Motor Company (Ford) is recalling certain 2015-2019 Flex, 2015 Explorer, Lincoln MKT, Lincoln MKZ, 2015-2016 C-Max, Escape, Taurus, 2016 Fusion, 2018-2019 Taurus, 2019 Lincoln MKT, Fiesta, and 2020 Mustang vehicles. The rearview camera may display a distorted, intermittent, or blank image when the vehicle is in reverse.
A rearview camera that fails to properly display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
20V072000 2020-02-10
Suspension:rear
Ford Motor Company (Ford) is recalling certain 2013-2018 Lincoln MKT and Ford Flex and Taurus vehicles with the Police Interceptor or SHO Performance Pack. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
16V621000 2016-08-25
Fuel system, gasoline:delivery:fuel pump
Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump.
A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash.
15V464000 2015-07-24
Parking brake
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.
Fuel / propulsion 9,800 mi 1.8 yr in service
APPARENTLY MY "THROTTLE BODY" ELECTRONICS WENT BAD AND CAUSED MY ENGINE TO STOP WHILE I WAS IN FAST LANE OF FREEWAY...BARELY MADE IT TO THE SHOULDER. NO WARNING UNTIL AFTER CAR WAS OFF. DEALER WAS "AWARE" OF THIS PROBLEM WITH THIS 2015 FORD ENGINE ALTHOUGH FORD HASN'T DONE ANYTHING TO WARN CUSTOMERS OR RECALL TO FIX..IT IS NOTICED HOWEVER IN SAFETY ISSUES WITH ORGS. IT IS INEXCUSABLE THAT THE CARE WILL NOT WARN OF PENDING PROBLEM, AND TURNS OFF ON ITS ON (OR SLOWS DOWN TO CRAWL) AND FORD HAS NOT TAKEN ACTION ON PROBLEM THEY ARE AWARE OF.
Fuel / propulsion 27,000 mi 2.8 yr in service crash / fire / tow
DRIVING THE VEHICLE ON THE HIGHWAY AND HEARD A CLUNK AND FELT A SLIGHT LOSS OF POWER AND CONTROL. PULLED OVER TO CHECK VEHICLE AND NOTICED FLAMES COMING UNDERNEATH THE ENGINE COMPARTMENT. CAR SOON BECAME ENGULFED AND WAS A TOTAL LOSS. THE ORIGIN AND CAUSE EXPERT HIRED BY OUR INSURANCE COMPANY SUSPECTS AN INJECTOR LINE CAME LOOSE ON THE ENGINE AND SPRAYED FUEL ONTO EXHAUST MANIFOLD.
Fuel / propulsion 32,000 mi 3.3 yr in service
I WAS DRIVING APPROXIMATELY 45 MPH UPHILL WHEN SUDDENLY, AND WITHOUT WARNING, THE FLEX DECELERATED TO A COASTING SPEED. I WAS ABLE TO PULL INTO A TURN LANE BUT UNABLE TO ACCELERATE. THE WRENCH LIGHT CAME ON. I TURNED OFF THE CAR AND TURNED IT BACK ON. THE WRENCH LIGHT WAS ON AND THEIR WAS ABILITY TO ACCELERATE BEYOND CRAWLING. I TURNED THE CAR OFF AND BACK ON AND WAS ABLE TO DRIVE NORMALLY TO WORK.
Steering 69,000 mi 3.9 yr in service
POWER STEERING SUDDENLY FAILED. SYSTEM WARNED OF VSC FAULT, THEN STEERING ASSIST FAULT, THEN THERE WAS NO POWER ASSIST, AT 50MPH. I WAS DRIVING STRAIGHT ON AN AIRPORT ACCESS ROAD. THE PROBLEM PERSISTED FOR A 2 MILES OR SO, WHEN I WAS ABLE TO GET IT OFF THE ROAD SAFELY. WHEN I TURNED OFF THE IGNITION AND RE-STARTED A FEW MINUTES LATER, THE PROBLEM WAS GONE, AS WERE THE WARNINGS.