3.6% of complaints about the 2005 Volkswagen Passat came in the first year, which is unremarkable for a 2005 vehicle — around the middle of the 245 model-years on record. The median complaint arrives at 5.3 yr in service. The most-reported system is engine cooling (50 complaints), typically at 4.5 yr or about 79,000 miles.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the af
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
2005 VOLKSWAGEN PASSAT DEVELOPED PROBLEMS WITH STALLING.*MR THE CONSUMER WAS TOLD BY THE DEALER, THE ENGINE WAS DAMAGED.
DT*: THE CONTACT STATED WHILE DRIVING 35 MPH UPHILL, THERE WAS POPPING NOISE FOLLOWED BY A LOSS OF ALL POWER. AFTER THE INITIAL ENGINE STALL, THE ENGINE WAS RESTARTED, BUT STALLED AGAIN. THE VEHICLE WAS TOWED TO A DEALER FOR INSPECTION. THE DEALER DETERMINED THERE WAS A FAILED CONNECTION OF THE INTER-COOLER HOSE AND PRESSURIZED HOSE THAT CONNECTS TO THE TURBO CHARGER. THE DEALER REPLACED THE HOSE FITTINGS ON THE TURBO CHARGER. UPDATED 6/27/2006 - THE CONSUMER FEELS THAT THE HOSE CONNECTION MECHANISM WASN'T SUFFICIENT TO SUPPORT THE HIGH PRESSURE CREATED BY THE TURBO. *NM
I HAVE LEASED A 2005 VW PASSAT. I CHANGED MY OIL ON A REGULAR BASIS, MY MECHANIC DID NOT WRITE THE IN MILEAGE OR OUT MILEAGE WHEN HE GAVE ME MY RECEIPT. MY CAR BROKE DOWN ON THE HIGHWAY AND VW STATES THAT I NEED A NEW MOTOR DUE TO SLUDGE IN THE MOTOR. THE ARE TELLING ME MY RECEIPTS ARE NOT GOOD ENOUGH AND WON'T COVER THE MOTOR. I HAVE SEARCHED THE WEB AND SEE I'M NOT THE ONLY ONE WITH THIS PROBLEM. THE PALISADES, NY VW ARE IMPOSSIBLE TO DO BUSINESS WITH. I'M NOT GETTING A NEW MOTOR! *TR