7.4% of complaints about the 2003 GMC Sierra 2500 came in the first year, which is unremarkable for a 2003 vehicle — around the middle of the 228 model-years on record. The median complaint arrives at 7.9 yr in service. The most-reported system is service brakes, hydraulic (44 complaints), typically at 8.1 yr or about 57,833 miles.
CERTAIN FEDERAL-MOGUL NATIONAL AND CARQUEST AFTERMARKET HUB ASSEMBLIES, P/N 515058, SOLD FOR USE ON 2001-2006 GENERAL MOTORS 1500 AND 2500 4WD TRUCKS. ON THE SUBJECT HUB ASSEMBLIES, THE ABS SENSOR CORD DEPARTS FROM THE HUB ASSEMBLY AT A 90 DEGREE ANGLE. AS A RESULT, THERE IS A FIT ISSUE WITH THE BRAKE ROTOR DUST SHIELD INTERFERING WITH THE ABS SENSOR CORD. IF THE HUB ASSEMBLY IS INSTALLED DESPITE THIS INTERFERENCE, THE GAP BETWEEN THE ABS SENSOR AND THE TONE WHEEL MAY BE ALTERED. THIS MAY WEAKEN THE OUTPUT OF THE ABS SENSOR. DIMINISHED OUTPUT COULD RESULT IN AN UNWANTED ABS ACTIVATION AT
IF STOPPING DISTANCE IS LIMITED, A VEHICLE CRASH COULD OCCUR.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
CERTAIN FABTECH AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS71000 AND FTS71001, INSTALLED FOR USE ON CERTAIN 2001-2006 GM C/K 2500 PICK UP TRUCKS AND SPORT UTILITY VEHICLES. THE PIN LOCATED INSIDE THE PITMAN ARM CAN SHEAR OFF DUE TO A REVERSE BENDING FATIGUE CONDITION, RESULTING IN A TOTAL LOSS OF STEERING CONTROL.
LOSS OF STEERING CONTROL COULD LEAD TO A VEHICLE CRASH WITH POTENTIAL INJURY OR DEATH.
WHEN THE CONSUMER MADE A STOP, HE NOTICED THE TRAILER BRAKES DID NOT WORK. THE CONSUMER THEN RECEIVED A NOTICE IN THE MAIL REGARDING THE WIRING HARNESS IN WHICH GMC HAD SWITCHED TWO OF THE WIRES ON THE TRUCK AT THE FACTORY. THE CONSUMER PURCHASED A NEW BRAKE CONTROLLER BECAUSE IT BURNED UP . *AK *JB
INSTRUMENT PANEL CLUSTER COMPONENTS FAILED THUS ALL GAUGES ON DASH BOARD WENT "FLAT"/BACK TO -0-; VEHICLE DID OPERATE HOWEVER COULD NOT EVEN READ HOW MUCH GAS WAS IN TANK. ALSO AS OF MILEAGE OF 13312 NOTICE VEHICLE BEGAN TO USE OIL, AS OF 26300 AFTER WATCHING THE VEHICLE NOTICED THAT IT WAS EXTREMELY LOW; APPARENTLY THE VEHICLE HAS BEEN LEAKING OIL ON THE INTAKE - LOOSING ALMOST 2 QUARTS OF OIL - ON A NEWER VEHICLE IT SHOULD NOT BE USING THIS MUCH OIL. *LA
I HAVE A 2003 GMC DIESEL PICKUP. I HAVE HAD THE VEHICLE IN TWICE FOR ELECTRICAL REPAIRS IN THE LAST 9 MONTHS. THE ELECTRICAL PROBLEMS OBSERVED INCLUDE: AIRCONDITIONER CUTTING IN/OUT, RADIO CUTTING IN/OUT, POWER WINDOWS NOT WORKING, DASH GAUGES CUTTING IN/OUT, IDIOT LIGHTS COMING ON (ABS, BRAKES, CHECK ENGINE ETC). IT WAS REPAIRED ONCE BY THE DEALERSHIP AT A COST OF $500. NOW, 9 MONTHS LATER, THE VEHICLE IS BACK IN FOR THE EXACT SAME PROBLEM. THE TECHNICIAIN TOOK IT FOR A RIDE AND HAD SO MANY PROBLEMS, HE WAS AFRAID HE WOULDN'T MAKE IT BACK TO THE DEALERSHIP.
VEHICLE STARTED TO MAKE NOISE. CONSUMER TOOK THE VEHICLE TO THE DEALER TO HAVE THE TIRES CHECKED. FRONT TIRE AXLE NUT WAS FOUND TO BE LOOSE. ALSO, THE ROTORS AND BEARINGS HAD TO BE REPLACED. *AK