19.1% of complaints about the 2001 Toyota Highlander came in the first year, which is unremarkable for a 2001 vehicle — around the middle of the 216 model-years on record. The median complaint arrives at 4.1 yr in service. The most-reported system is visibility (22 complaints), typically at 5.7 yr or about 83,000 miles.
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE BRAKES ARE APPLIED.
THE INCREASED PEDAL STROKE WILL LENGTHEN THE STOPPING DISTANCE OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
REAR WINDOW REFLECTED SOUND. IF HAD ONE REAR WINDOW ALL WAY DOWN IT CREATED WIND VACCUM THAT HURT EAR DRUMS. CAN CRACK RIGHT REAR WINDOW. *AK
WHILE DRIVING ABOUT ANY MPH WITH REAR WINDOW DOWN WILL MAKE A LOT OF VIBRATION AND A LOUD NOISE THAT COULD NOT BE TAKEN BY CONSUMER. DEALER SAID THAT THIS WAS NOT COMMON ON THIS VEHICLE.*AK *SLC
WHEN THE REAR WINDOW IS ROLLED DOWN THE CAR CREATE VARYING PRESSURE IN THE CAR CAUSING IF NOT CAREFUL THE EAR DRUM RUPTURE. ONE CAN NOT DRIVE THIS CAR WITH REAR WINOW ROLLED DOWN.
RECALL# 01V228000/ MANUFACTURER'S RECALL SSC10G; CONSUMER GOT RECALL NOTICE ON JUL 30, 2001 AND MADE AN APPOINTMENT FOR AUG 1, 2001. TOOK VEHICLE IN, AND DEALER DIDNOT HAVE PARTS. GAVE DEALER PHONE # TO CALL WHEN PARTS COME IN. ALSO, CONSUMER CALLED DEALER ON AUG 16 ABOUT PARTS, AND DEALER STATED HAD PARTS, AND DID NOT KNOW WHETHER THEY HAVE ANYMORE. *AK